Multiquip manual AR13D RIDE-ON Roller General Information, Tipping Rollovers

AR13D RIDE-ON ROLLER — GENERAL INFORMATION

DANGER - Transporting Safety

DO NOT allow personnel to stand under or near any suspended machine. Serious injury or death may result.

CAUTION - Use CERTIFIED Lifting Devices

ONLY! use approved certified lifting devices capable of lifting at least 4,000 lbs. (1,814 Kg.).

CAUTION - Lifting the Roller

When lifting of the roller is required, only use the provided lifting eyes to lift the roller. Using other sections of the roller for lifting purposes may cause severe damage to the roller.

OPERATING ON SLOPES

Tipping (Rollovers)

NEVER! operate the roller on side slopes (Figure 3). The possibility exist that the roller could tip over (roll over), thus causing bodily harm even death and serious damage to the equipment.

SIDE TO SIDE

OPERATION

NOT RECOMMENDED

REAR

ROLLER

ROLL OVER

Special care must be taken when operating the roller on hills or slopes. There exist the possibility of serious injury to the operator and severe damage to the roller in the event of a roll over.ALWAYS operate the roller up and down hills rater than from side to side. For safe operation hillside slopes should not exceed 12 degree (27 % grade). See Figure 2 below.

MAXIMUM SLOPE

27%

Figure 2. Recommend Slope

Figure 3. Tipping (Rollover)

NEVER! operate the roller on side slopes. The roller may tip over causing injury to personnel and severe damage to the equipment

In the event the roller does tip over, if at all possible, try to shut- down the engine by turning the ignition key to the OFF position. Extreme care must be taken to prevent damage to the engine. When the roller has been tipped over, oil from the engine crankcase can flow into the combustion chamber, which can severely damage the engine the next time it is started.

IMMEDIATELY after a unit has tipped over upright the unit as soon as possible to prevent oil from leaking into the combustion chamber.

CAUTION - Roller Rollover Safety

To prevent damage to the engine after a rollover, the roller must NOT be started. NEVER start a roller after a rollover. CONTACT your nearest authorized multiquip dealer for instructions or servicing.

AR13D RIDE-ON TANDEM DRUM ROLLER — OPERATION & PARTS MANUAL — REV. #2 (09/15/11) — PAGE 17