Meco 7900 manual END of Cooking Session, Care and Maintenance

·Do not use the grill without the Drip Cup in place. Empty excess grease to avoid a fire under the grill.

·If you notice grease or other hot material dripping from the grill onto the valve, hose, or regulator, turn off the gas supply immediately. After the grill has cooled, determine the cause and correct it. After cleaning the valve and hose and regulator assembly, perform a leak test before continuing use. (See Performing a Leak Test.)

·Do not attempt to extinguish a grease fire with water or other liquids. Have an BC fire extinguisher accessible. Do not douse or spray the grill or cooking surfaces with water when hot. Burns from grease or the water splatters could occur.

·If your gas grill catches on fire:

-If the fire is in the gri ll portion and you can safely reach the control knobs on the control panel, then turn them to the off position.

-If the fire is in one of the hoses, and you can safely reach the LP cylinder valve, then shut the valve off.

-If the fire involves the cylinder, leave it alone, evacuate the area and call the fire department.

-If there is any type of fire that threatens either personal safety or endangers property, call the fire department.

·Do not wear loose clothing (example: hanging shirt tails, clothing with frills, etc.) around a gas grill while in use or hot.

·Do not lean your body over the gas grill when lighting it or while it is in use or hot.

·Do not touch hot surfaces. Use heat resistant gloves, long-handled tongs, or cooking mitts at all times since the grill will become very hot. Open the hood carefully when cooking to avoid burns from the hot air and steam trapped inside.

·Do not allow children to operate or play near a gas grill. Keep animals and bystanders out of the grill area. Do not leave grill unattended.

·Do not move an LP gas grill when in use or hot.

·When grill is not in use, turn off all grill control knobs, LP cylinder valve and disconnect the LP cylinder.

END OF COOKING SESSION

To reduce the risk of serious bodily injury, fire or death: · Allow grill and grease in the Drip Cup to completely

cool before emptying, handling parts, cleaning, moving or storage.

· Empty the Drip Cup after each cooking session so excessive grease does not accumulate.

· Never light the LP gas grill without the Drip Cup in place.

1) After each cooking session, close the hood and turn the grill burners to the “High” position and burn for five minutes. This procedure will burn off cooking residue, thus making cleaning easier. (Side Burner not affected)

2) When you have finished using your grill, turn the grill Control Knobs clockwise to the “Off” position.

3)Turn off the gas at the LP cylinder valve by turning the handle clockwise until it stops.

4)Wait until the grill is cool before closing the hood, cleaning or putting on the cover.

5)Regularly clean your LP gas grill betw een uses and after extended storage periods. To maintain the condition and extend the life of your grill, we strongly recommend that the unit be covered when stored outside for any length of time, especially during the winter months.

CARE AND MAINTENANCE

To reduce the risk of a cut injury:

· Be careful or wear protective gloves when cleaning grill parts that have sharp edges.

1)Remove Drip Cup, Cooking Grid, and Flame Diffuser.

2)Drip Cup-Wash the Drip Cup with soap and water.

3)Grill Body and Cart-Remove excess grease and/or fat with a soft plastic or wooden scraper. Do not use steel wool or other abrasive cleaners that can scratch painted or porcelain coated surfaces. It is not necessary to remove all the grease from the body. Wipe it down with paper towels or soft damp cloth.

4)Warming Rack-Clean if necessary with soap and water.

5)Cooking Grid/Flame Diffuser. Clean the residue off with hot soap and water, or baking soda. For stubborn stains, use a non-abrasive scouring powder. Do not use steel wool or other abrasive cleaners that can scratch the porcelain coated surfaces. This can cause foods to stick on the Cooking Grids.

6)All other Cleaning-For further cleaning, use hot soapy water and a cloth, or nylon-bristled brush only. Do not immerse the gas controls or manifold in water. (Avoid getting water in the Burner Holes.)

7)Burners-Burning off the residue after cooking will keep the burners clean with normal usage, provided the Burners are operating correctly. Clean the the Burners annually, or whenever heavy build-up is found, to ensure that there are no signs of blockage (debris, insects) in either the burner portholes, the primary air inlet, or the neck of the burners. (See Burner Cleaning instructions.)

8)After cleaning, replace all the cleaned parts. Re-tighten Burner and Heat Shield screws.

19