Char-Broil 463411512 Sideburner Ignitor Lighting, Sideburner Match Lighting, Burner Flame Check

Page 12

Ignitor Lighting (continued)

8.For grills equipped with ELECTRONIC IGNITION at each burner:

Repeat steps 4 through 6 to light each burner.

9.Once each burner has ignited, turn knobs to desired setting.

WARNING

Turn controls and gas source or tank OFF when not in use.

CAUTION

If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury.

Match-Lighting

sDo not lean over grill while lighting.

1.Open lid. Turn ON gas at LP cylinder.

2.Place match into match holder (hanging from side panel of grill). Light match; then light burner by placing match through the match light hole on right or left side of grill.

3.Push in and turn far right or far left burner knob to the HI position, depending on match light hole selected. Be sure burner lights and stays lit.

4.Light adjacent burners in sequence by pushing knobs in and turning to the HI position.

NOTE: Your grill may NOT be equipped with a Sideburner!

Sideburner Ignitor Lighting

sDo not lean over grill while lighting.

1.Open sideburner lid. Turn ON gas at LP cylinder.

2.Turn sideburner knob to the HI position, push and hold ELECTRONIC IGNITOR button.

3.If sideburner does NOT light within 5 seconds, turn knob to OFF, wait 5 minutes, then

repeat lighting procedure.

Sideburner Match Lighting

1.Open sideburner lid. Turn ON gas at LP cylinder.

2.Place lit match near burner.

3. Turn sideburner knob to the HI position.

Be sure burner lights and stays lit.

Burner Flame Check

•Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW position than seen on HI. Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the Troubleshooting Section.

HI

LOW

Turning Grill Off

•Turn all knobs to the OFFposition. Turn LP cylinder OFF by turning hand-wheel clockwise to a full stop.

Ignitor Check

•Turn gas off at LP cylinder. Press and hold electronic ignitor button. "Click" should be heard and spark seen each time between each collector box or burner and electrode. See "Troubleshooting" if no click or spark.

Valve Check

•Important: Make sure gas is off at LP cylinder before checking valves. Knobs lock in OFF position. To check valves, first push in knobs and release, knobs should spring back. If knobs do not spring back, replace valve assembly before using grill. Turn knobs to LOW position then turn back to OFF position. Valves should turn smoothly.

Hose Check

•Before each use, check to see if hoses are cut or worn or kinked. Replace damaged hoses before using grill. Use only valve/hose/regulator specified by manufacturer.

General Grill Cleaning

•Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a grill cleaner with scrub brush on insides of grill lid and bottom. Rinse and allow to completely air dry. Do not apply a caustic grill/oven cleaner to painted surfaces.

•Plastic parts: Wash with warm soapy water and wipe dry.

useDo not citrisol, abrasive cleaners, degreasers or a concentrated grill cleaner on plastic parts. Damage to and failure of parts can result.

•Porcelain surfaces: Because of glass-like composition, most residue can be wiped away with baking soda/water solution or specially formulated cleaner. Use nonabrasive scouring powder for stubborn stains.

•Painted surfaces: Wash with mild detergent or nonabrasive cleaner and warm soapy water. Wipe dry with a soft nonabrasive cloth.

•Stainless steel surfaces: To maintain your grill’s high quality appearance, wash with mild detergent and warm soapy water and wipe dry with a soft cloth after each use. Baked-on grease deposits may require the use of an abrasive plastic cleaning pad. Use only in direction of brushed finish to avoid damage. Do not use abrasive pad on areas with graphics.

•Cooking surfaces: If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

12

Page 11 Page 13
Image 12
Page 11 Page 13
Contents Product Guide Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionTemperature Convective Grills only Grilling Guide Getting StartedFirst Time Use Lava Rock / BriquettesFood Safety Grilling Guide GrillingDirect Cooking Indirect CookingUsda Recommended Safe Minimum Internal Temperatures Grilling Guide Tips & TricksGrilling Guide Cleaning Your Grill USE and Care LP Liquefied Petroleum GasLP Cylinder Filling UL listed Overfill ProtectionFor your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Ignitor LightingSDo not lean over grill while lighting Open lid during lightingGeneral Grill Cleaning Sideburner Ignitor LightingSideburner Match Lighting Burner Flame CheckCleaning the Burner Assembly Storing Your GrillVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderLimited Warranty All Parts Year from date of purchaseParts List Key Qty DescriptionParts Diagram Assembly Bottom Shelf and LegsWheels and Leg Extenders Cone side of wheel against legSide Braces Turn cart uprightFront Panels Tank Exclusion Brace Grill HeadSide Shelf and Fascias Left Side Shelf Sideburner Shelf Sideburner Valve and Bezel Sideburner Ignition Wire Control KnobGrease Tray and Grease Pan Heat DiffusersInstall Grates, Warming Rack and Battery AAA BatteryTroubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionPage Mail to / Enviar a / Envoyer à

463411512 specifications

The Char-Broil 463411512 is a standout grill designed for both beginner and seasoned grill enthusiasts. With its rugged construction and innovative features, it offers a premium grilling experience that caters to a range of outdoor cooking needs.

One of the main features of the Char-Broil 463411512 is its four-burner system, which provides a total of 36,000 BTUs of cooking power. This impressive heat output ensures that users can achieve high temperatures for searing meats or cooking at lower temperatures for more delicate foods. The burners are made from stainless steel, known for its durability and resistance to corrosion, ensuring that they can withstand the outdoor elements.

The cooking surface of the Char-Broil 463411512 is generous, boasting 425 square inches of primary cooking space along with an additional 150 square inches of warming rack space. This ample grilling area allows for cooking multiple items at once, making it perfect for family gatherings or barbecues with friends. The grill's grates are porcelain-coated, providing excellent heat retention and ensuring that food does not stick, facilitating easier cleanup.

Another notable feature is the integrated TRU-Infrared cooking technology. This unique system helps to eliminate flare-ups and provides even heat distribution across the grilling surface. The TRU-Infrared technology ensures that food cooks evenly, retaining moisture and flavor, which helps to achieve perfectly grilled meats and vegetables every time.

The Char-Broil 463411512 also comes equipped with an electronic ignition system, ensuring reliable starts with just the push of a button. This convenient feature eliminates the need for matches or lighters, making the grilling process smoother and less cumbersome.

Additional characteristics of this grill include side shelves that provide extra workspace for food prep and a side burner that offers versatility for cooking side dishes or sauces. The grill is mounted on heavy-duty wheels, allowing for easy mobility and storage.

Designed with both functionality and aesthetics in mind, the Char-Broil 463411512 features a sleek stainless steel finish that adds a modern touch to any outdoor space. Overall, the Char-Broil 463411512 stands out as a versatile and efficient grill, making it an exceptional choice for anyone looking to enhance their outdoor cooking experience.
Top Page Image Contents