Char-Broil 463411512 manual Troubleshooting, Emergencies Possible Cause Prevention/Solution

Page 27

DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department.

Emergencies

Possible Cause

Prevention/Solution

 

 

 

Gas leaking from

• Damaged hose.

• Turn off gas at LP cylinder or at source on natural gas systems. If

cracked/cut/burned

 

anything but burned, replace valve/hose/regulator. If burned,

hose.

 

discontinue use of product until a plumber has investigated cause

 

 

and corrections are made.

Gas leaking from LP

• Mechanical failure due to rusting or

• Replace LP cylinder.

cylinder.

mishandling.

 

Gas leaking from LP

• Failure of cylinder valve from

• Turn off LP cylinder valve. Return LP cylinder to gas supplier.

cylinder valve.

mishandling or mechanical failure.

 

Gas leaking between

• Improper installation, connection not

• Turn off LP cylinder valve. Remove regulator from cylinder and

LP cylinder and

tight, failure of rubber seal.

visually inspect rubber seal for damage. See LP Cylinder Leak Test

regulator connection.

 

and Connecting Regulator to the LP Cylinder.

Fire coming through

• Fire in burner tube section of burner due

• Turn off control knobs and LP cylinder valve. Leave lid open to

control panel.

to blockage.

allow flames to die down. After fire is out and grill is cold, remove

 

 

burner and inspect for spider nests or rust. See Natural Hazard

 

 

and Cleaning the Burner Assembly pages.

Grease fire or

• Too much grease buildup in burner area.

• Turn off control knobs and LP cylinder valve. Leave lid open to

continuous excessive

 

allow flames to die down. After cooling, clean food particles and

flames above cooking

 

excess grease from inside firebox area, grease tray, and other

surface.

 

surfaces.

 

 

 

Troubleshooting

Problem

Burner(s) will not light using ignitor.

(See Electronic Ignition Troubleshooting also)

Continued on next page.

Possible Cause

GAS ISSUES:

•Trying to light wrong burner.

•Burner not engaged with control valve.

•Obstruction in burner.

•No gas flow.

•Vapor lock at coupling nut to LP cylinder.

•Coupling nut and LP cylinder valve not fully connected.

ELECTRICAL ISSUES:

•Electrode cracked or broken; “sparks at crack.”

•Electrode tip not in proper position.

•Wire and/or electrode covered with cooking residue.

•Wires are loose or disconnected.

•Wires are shorting (sparking) between ignitor and electrode.

Prevention/Solution

•See instructions on control panel and in Use and Care section.

•Make sure valves are positioned inside of burner tubes.

•Ensure burner tubes are not obstructed with spider webs or other matter. See cleaning section of Use and Care.

•Make sure LP cylinder is not empty. If LP cylinder is not empty, refer to “Sudden drop in gas flow.”

•For a grill equipped with the AUTO-CLEAN™ feature, make sure the AUTO-CLEAN™ valve is set to “Grill”

•Turn off knobs and disconnect coupling nut from LP cylinder. Reconnect and retry.

•Turn the coupling nut approximately one-half to three-quarters additional turn until solid stop. Tighten by hand only - do not use tools.

•Replace electrode(s).

Main Burners:

•Tip of electrode should be pointing toward gas port opening on burner. The distance should be 1/8” to 1/4”. Adjust if necessary.

Sideburner:

•Tip of electrode should be pointing toward gas port opening on burner. the distance should be 1/8” to 3/16”. Adjust if necessary.

•Clean wire and/or electrode with rubbing alcohol and clean swab.

•Reconnect wires or replace electrode/wire assembly.

•Replace ignitor wire/electrode assembly.

• Dead battery.

• Replace with a new alkaline battery.

27

Page 26 Page 28
Image 27
Page 26 Page 28
Contents Date Purchased Product GuideThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsLava Rock / Briquettes Temperature Convective Grills onlyGrilling Guide Getting Started First Time UseIndirect Cooking Food SafetyGrilling Guide Grilling Direct CookingGrilling Guide Tips & Tricks Usda Recommended Safe Minimum Internal TemperaturesGrilling Guide Cleaning Your Grill UL listed Overfill Protection USE and CareLP Liquefied Petroleum Gas LP Cylinder FillingFor your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting SDo not lean over grill while lightingBurner Flame Check General Grill CleaningSideburner Ignitor Lighting Sideburner Match LightingTurn gas OFF at control knobs and LP cylinder Cleaning the Burner AssemblyStoring Your Grill Very Important Burner tubes must reengage valveAll Parts Year from date of purchase Limited WarrantyKey Qty Description Parts ListParts Diagram Cone side of wheel against leg AssemblyBottom Shelf and Legs Wheels and Leg ExtendersSide Braces Turn cart uprightFront Panels Grill Head Tank Exclusion BraceSide Shelf and Fascias Left Side Shelf Sideburner Shelf Sideburner Valve and Bezel Control Knob Sideburner Ignition WireHeat Diffusers Grease Tray and Grease PanAAA Battery Install Grates, Warming Rack and BatteryEmergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Mail to / Enviar a / Envoyer à

463411512 specifications

The Char-Broil 463411512 is a standout grill designed for both beginner and seasoned grill enthusiasts. With its rugged construction and innovative features, it offers a premium grilling experience that caters to a range of outdoor cooking needs.

One of the main features of the Char-Broil 463411512 is its four-burner system, which provides a total of 36,000 BTUs of cooking power. This impressive heat output ensures that users can achieve high temperatures for searing meats or cooking at lower temperatures for more delicate foods. The burners are made from stainless steel, known for its durability and resistance to corrosion, ensuring that they can withstand the outdoor elements.

The cooking surface of the Char-Broil 463411512 is generous, boasting 425 square inches of primary cooking space along with an additional 150 square inches of warming rack space. This ample grilling area allows for cooking multiple items at once, making it perfect for family gatherings or barbecues with friends. The grill's grates are porcelain-coated, providing excellent heat retention and ensuring that food does not stick, facilitating easier cleanup.

Another notable feature is the integrated TRU-Infrared cooking technology. This unique system helps to eliminate flare-ups and provides even heat distribution across the grilling surface. The TRU-Infrared technology ensures that food cooks evenly, retaining moisture and flavor, which helps to achieve perfectly grilled meats and vegetables every time.

The Char-Broil 463411512 also comes equipped with an electronic ignition system, ensuring reliable starts with just the push of a button. This convenient feature eliminates the need for matches or lighters, making the grilling process smoother and less cumbersome.

Additional characteristics of this grill include side shelves that provide extra workspace for food prep and a side burner that offers versatility for cooking side dishes or sauces. The grill is mounted on heavy-duty wheels, allowing for easy mobility and storage.

Designed with both functionality and aesthetics in mind, the Char-Broil 463411512 features a sleek stainless steel finish that adds a modern touch to any outdoor space. Overall, the Char-Broil 463411512 stands out as a versatile and efficient grill, making it an exceptional choice for anyone looking to enhance their outdoor cooking experience.
Top Page Image Contents