Char-Broil 463411512 manual Assembly, Bottom Shelf and Legs, Wheels and Leg Extenders

Page 17

ASSEMBLY

1

Bottom Shelf and Legs

□ Attach legs to bottom shelf with 1/4-20x2-3/8” machine screws. Be sure that metal tabs on legs face to cart

 

interior as shown.

Left Rear Leg

Left Front Leg

Metal Tabs

Right Rear Leg

Metal Tabs

Right Front Leg

Bottom Shelf

1/4-20x2-3/8”

Machine Screws

Qty. 8

2

Wheels and Leg Extenders

□ Turn cart upside down.

 

□ Insert axle rod through wheel, wheel spacer, right legs, another wheel spacer and wheel. Secure with one

 

axle washer and hitch pin. Be sure that cone side of each wheel is against leg.

 

□ Push leg extenders into left legs.

Leg Extenders

 

Wheel

 

Front Wheel Spacer

 

Hitch Pin

 

Qty. 1

Axle Rod

Wheel Spacer

 

Hitch Pin

"Cone" side of wheel against leg

Axle Washer

Qty. 1

Axle Washer

17

Page 16 Page 18
Image 17
Page 16 Page 18
Contents
Date Purchased Product GuideThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsGrilling Guide Getting Started Temperature Convective Grills onlyFirst Time Use Lava Rock / BriquettesGrilling Guide Grilling Food SafetyDirect Cooking Indirect CookingGrilling Guide Tips & Tricks Usda Recommended Safe Minimum Internal TemperaturesGrilling Guide Cleaning Your Grill LP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UL listed Overfill ProtectionLP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Turn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjurySDo not lean over grill while lighting Open lid during lightingSideburner Ignitor Lighting General Grill CleaningSideburner Match Lighting Burner Flame CheckStoring Your Grill Cleaning the Burner AssemblyVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinderAll Parts Year from date of purchase Limited WarrantyKey Qty Description Parts ListParts Diagram Bottom Shelf and Legs AssemblyWheels and Leg Extenders Cone side of wheel against legFront Panels Side BracesTurn cart upright Grill Head Tank Exclusion BraceSide Shelf and Fascias Left Side Shelf Sideburner Shelf Sideburner Valve and Bezel Control Knob Sideburner Ignition WireHeat Diffusers Grease Tray and Grease PanAAA Battery Install Grates, Warming Rack and BatteryEmergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Mail to / Enviar a / Envoyer à