OWNER’S MANUAL
FIREPLACE INSTALLATION
Continued
CONNECTING FIREPLACE TO GAS SUPPLY
Installation Items Needed
CHECKING GAS
CONNECTIONS
WARNING: Test all gas pip- ing and connections for leaks after installing or servicing. Cor- rect all leaks at once.
3. | Pressurize supply piping system by ei- |
| ther opening propane/LP supply tank |
| valve for propane/LP gas fireplace or |
| opening main gas valve located on or near |
| gas meter for natural gas fireplace, or |
| using compressed air. |
4. | Check all joints of gas supply piping |
| system. Apply commercial leak test |
| solution to all gas joints. Bubbles form- |
•5/16" hex socket wrench or
•sealant (resistant to propane/LP gas, not provided)
1.Open lower louver door panel by gen- tly pulling forward.
2.Route flexible gas line (provided by installer) from equipment shutoff valve to fireplace. Route flexible gas supply line through one of the access holes on side of fireplace.
3.Attach a 45° flare union gas connector to flexible gas line from gas supply (see Figure 36). Connect flare union to flex- ible gas line attached to gas regulator of fireplace (see Figure 36).
4.Check all gas connections for leaks. See Checking Gas Connections.
WARNING: Never use an open flame to check for a leak. Apply commercial leak test solution to all gas joints. Bubbles forming show a leak. Correct all leaks at once.
Pressure Testing Gas Supply Piping System
Test Pressures In Excess Of 1/2 PSIG (3.5 kPa)
1.Disconnect appliance with its appliance main gas valve (control valve) and equipment shutoff valve from gas supply piping system. Pressures in excess of 1/2 psig (3.5 kPa) will damage fireplace gas regulator.
2.Cap off open end of gas pipe where equipment shutoff valve was connected.
ing show a leak. Correct all leaks at |
once. |
5. Reconnect fireplace and equipment |
shutoff valve to gas supply. Check re- |
connected fittings for leaks. |
To Fireplace
Gas Valve
Flare Union
| Equipment Shutoff Valve | ||
Flexible Gas Line from |
| To Gas | |
Fireplace Gas Valve |
| ||
| Supply | ||
Provided with Fireplace |
| ||
Flexible Gas Line from | (Natural) | ||
| |||
Equipment Shutoff Valve | To External | |
Provided by Installer | ||
Regulator | ||
| ||
| (Propane/LP) | |
Figure 36 - Attaching Flexible Gas Lines Together |
|
Continued
106517 | 19 |