Char-Broil 466247310 Now you may fully tighten lower screws on upper back panel, Front of Shelf

Page 19

9

Insert tabs on left sideburner shelf assembly into rectangular slots in side of firebox, shown A.

Attach rear of shelf using one 1/4-20x3/4”screw, 7mm flat washer, 7mm lock washer and 1/4”nut in upper hole; and using 1/4-20x1½”screw, 7mm lock washer, 7mm flat washer in lower hole, shown B/C.

Attach front of shelf and fascia using two 1/4-20x3/4”screws, 7mm flat washers, 7mm lock washers and 1/4”nuts, and one #8x3/8” self-tapping screw with large washer, shown C/D/E.

Now you may fully tighten lower screws on upper back panel.

B

1/4-20x3/4” screw

1/4-20x1½” screw

7mm lock washer

7mm flat washer

C

7mm flat washer

7mm lock washer

1/4”nut

A

7mm flat washer

7mm lock washer

1/4”nut



Front of Shelf	D
Front of Shelf

1/4-20x3/4” screw

#8x3/8” tapping

screw

large flat washer

1/4”nut

Back of main control panel

E

Control panel

1/4-20x3/4” screw

Note:

Insert this screw from the back of main control panel

7mm lock washer

7mm flat washer

19

Image 19

Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsUL listed Overfill Protection USE and CareLP Liquefied Petroleum Gas LP Cylinder FillingUseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Main Burner Lighting Instructions For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Check Side Burner Lighting InstructionsSideburner Match Lighting Burner Flame CheckSurfaces General Grill CleaningCooking surfaces If a bristle brush is used to clean any Storing Your GrillTurn gas off at control knobs and LP cylinder Cleaning the Burner AssemblyItems Manufacturer will not PAY for Limited WarrantyNot Pictured Parts ListKey Qty Description Parts Diagram Bottom shelf Rear AssemblyFront Fixed caster Locking casterGrill head Regulator hose Lower back panel Rear of Shelf Screws and Washers removed from valve bracket Front of Shelf Now you may fully tighten lower screws on upper back panelBack of main control panel Holes on fascia to Sideburner lid Front brace Page Wire Frontbrace Right door Cooking grate Cylinder screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionWarranty Registration Department Box Columbus, GA