Char-Broil 463263110 manual Assembly, Fixed caster Locking caster, Bottom shelf Rear

Page 14

ASSEMBLY

1

Attach the two locking casters at the rear of the bottom shelf and the two fixed casters at the front. Use the provided caster wrench to fully tighten casters.

Fixed caster

Locking caster

Front

Bottom shelf

Rear

2	Attach side panels to bottom shelf using three
	1/4-20x1/2”screws, 7mm lock washers, and

7mm flat washers per panel.

IMPORTANT: Panel with large hole must be on Right side of bottom shelf.

Left side panel

Make sure side panels are pushed as far to the rear of bottom shelf as possible before fully tightening screws.

1/4-20x1/2” screw

7mm lock washer

7mm flat washer

Right side panel (with large hole)

Front

Magnet

14

Image 14

Contents Estimated assembly time 30 minutes Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionLP Cylinder Filling USE and CareLP Liquefied Petroleum Gas LP Cylinder Leak Test For your safetyUseDo not household cleaning agents. Damage to gas Turn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator Open lid during lighting For Safe Use of Your Grill and to Avoid Serious InjuryIgnitor Lighting Burner Flame Check Sideburner Ignitor LightingSideburner Match Lighting Ignitor CheckGeneral Grill Cleaning Storing Your GrillCleaning the Burner Assembly Turn gas off at control knobs and LP cylinderLimited Warranty Items Manufacturer will not PAY forParts List Key Qty DescriptionParts Diagram Bottom shelf Rear AssemblyFixed caster Locking caster 20x1/2 screws, 7mm lock washers,Grill head Regulator hose Temperature gauge stem Control panel Knob Back of the panelRear of Shelf Back of main control panelNow you may fully tighten lower screws on upper back panel Holes on fascia to Attach bezel 20x1½Sideburner burner Sideburner drip pan Wing nut Burner tube Front brace Page Wire AA battery CapRight door Cooking grate Cylinder screw at rear of cart Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA