Char-Broil 463263110 manual Grill head Regulator hose

Page 15

3

Place lower back panel between side panels at rear of bottom shelf. Make sure the slots are positioned as shown (A). Secure lower back panel to side panels using two 1/4-20x1/2”screws, 7mm lock washers, and 7mm flat washers on each side.

7mm flat washer 7mm lock washer 1/4-20x1/2” screw

 

Lower back panel

 

 

 

 

 

The vertical flange should be on left side

A

 

when the lower back panel is properly

 

 

installed

Vertical flange

4

This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart, aligning slots at bottom of grill head with posts on cart side panels. Make sure the regulator hose is hanging outside the cart. Grill head must face open side of cart.

Grill head

Regulator hose

15

Image 15
Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsUSE and Care LP Liquefied Petroleum GasLP Cylinder Filling For your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Ignitor LightingOpen lid during lighting Ignitor Check Sideburner Ignitor LightingSideburner Match Lighting Burner Flame CheckStoring Your Grill General Grill CleaningTurn gas off at control knobs and LP cylinder Cleaning the Burner AssemblyItems Manufacturer will not PAY for Limited WarrantyKey Qty Description Parts ListParts Diagram 20x1/2 screws, 7mm lock washers, AssemblyFixed caster Locking caster Bottom shelf RearGrill head Regulator hose Knob Back of the panel Temperature gauge stem Control panelBack of main control panel Rear of ShelfNow you may fully tighten lower screws on upper back panel 20x1½ Holes on fascia to Attach bezelSideburner burner Sideburner drip pan Wing nut Burner tube Front brace Page AA battery Cap WireRight door Cooking grate Cylinder screw at rear of cart Emergencies Possible Cause Prevention/Solution TroubleshootingAUTO-CLEAN Section Troubleshooting Electronic IgnitionPage Warranty Registration Department Box Columbus, GA