Char-Broil 463263110 manual Now you may fully tighten lower screws on upper back panel

Page 18

8

Insert flange on left sideburner shelf into side shelf brackets on side of firebox.

Attach left sideburner shelf using three 1/4-20x3/4”screws, 7mm lock washers, 7mm flat washers, 1/4” nuts, shown A. Attach rear of shelf using one 1/4-20x1½”screw, 7mm lock washer, and 7mm flat washer in lower hole, shown B. Attach front of shelf and fascia using one #8x3/8” self-tapping screw and large flat washer, shown C.

Under main control panel, attach front of shelf and fascia using one 1/4-20x3/4”screw, 7mm lock washer, 7mm flat washer and 1/4” nut, shown D/E.

Now you may fully tighten lower screws on upper back panel.

B

1/4-20x1½” screw

A

1/4-20x3/4” screw

7mm flat 7mm lock1/4”nut washer washer

1/4”nut E

7mm flat washer

7mm lock washer

		Flange
7mm lock	7mm flat	into
7mm lock	washer

Left sideburner shelf

Bracket

Fascia, left sideburner shelf

C

	large flat	#8x3/8” self-tapping
		screw
	washer

Back of main control panel

D

Control panel

1/4-20x3/4” screw

18

Image 18

Contents Estimated assembly time 30 minutes Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionUSE and Care LP Liquefied Petroleum GasLP Cylinder Filling For your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Ignitor LightingOpen lid during lighting Burner Flame Check Sideburner Ignitor LightingSideburner Match Lighting Ignitor CheckGeneral Grill Cleaning Storing Your GrillCleaning the Burner Assembly Turn gas off at control knobs and LP cylinderLimited Warranty Items Manufacturer will not PAY forParts List Key Qty DescriptionParts Diagram Bottom shelf Rear AssemblyFixed caster Locking caster 20x1/2 screws, 7mm lock washers,Grill head Regulator hose Temperature gauge stem Control panel Knob Back of the panelRear of Shelf Back of main control panelNow you may fully tighten lower screws on upper back panel Holes on fascia to Attach bezel 20x1½Sideburner burner Sideburner drip pan Wing nut Burner tube Front brace Page Wire AA battery CapRight door Cooking grate Cylinder screw at rear of cart Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA