Char-Broil 463263110 manual Temperature gauge stem Control panel, Knob Back of the panel

Page 16

5

On back of grill, place upper back panel between side panels and above lower back panel. Secure upper back panel, in lower hole, using one 1/4-20x1½”screw, 7mm lock washer, and 7mm flat washer on each side.

Do not fully tighten screws until side shelf installation is complete in later steps.

Upper back panel

1/4-20x1½” 7mm lock 7mm flat

screw washer washer

6

Pull out the knobs from control panel. Insert temperature gauge stem into the biger hole above knob bezel,shown A. Make sure the gauge is pushed in as far as it will go, then push the gauge downward until it clips into the panel, as shown in B/C. Re-install the knobs.

Temperature gauge stem

Temperature gauge

Control panel	Knob bezel

Knob

A

B

Back of the panel

C

16

Image 16

Contents Estimated assembly time 30 minutes Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UseDo not household cleaning agents. Damage to gas For your safetyLP Cylinder Leak Test Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Ignitor Lighting For Safe Use of Your Grill and to Avoid Serious InjuryOpen lid during lighting Sideburner Ignitor Lighting Sideburner Match LightingBurner Flame Check Ignitor CheckGeneral Grill Cleaning Storing Your GrillCleaning the Burner Assembly Turn gas off at control knobs and LP cylinderLimited Warranty Items Manufacturer will not PAY forParts List Key Qty DescriptionParts Diagram Assembly Fixed caster Locking casterBottom shelf Rear 20x1/2 screws, 7mm lock washers,Grill head Regulator hose Temperature gauge stem Control panel Knob Back of the panelRear of Shelf Back of main control panelNow you may fully tighten lower screws on upper back panel Holes on fascia to Attach bezel 20x1½Sideburner burner Sideburner drip pan Wing nut Burner tube Front brace Page Wire AA battery CapRight door Cooking grate Cylinder screw at rear of cart Troubleshooting Emergencies Possible Cause Prevention/SolutionAUTO-CLEAN Troubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA