Char-Broil 463230513 Leak Testing Valves, Hose and Regulator, Turn all grill control knobs to OFF

Page 10

Hold coupling nut and regulator as shown for proper connection to LP cylinder valve.

6.Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools.

NOTE:

If you cannot complete the connection, disconnect regulator and repeat steps 5 and 6. If you are still unable to complete the

connection, do not use this regulator!

DANGER

•Do not insert any tool or foreign object into the valve outlet or safety relief valve. You may damage the valve and cause a leak. Leaking propane may result in explosion, fire, severe personal injury, or death.

WARNING

•Outdoor gas appliance is not intended to be installed in or on a boat.

•Outdoor gas appliance is not intended to be installed in or on an RV.

•Never attempt to attach this grill to the self-contained LP gas system of a camper trailer or motor home.

•Do not use grill until leak-tested.

•If a leak is detected at any time, STOP and call the fire department.

•If you cannot stop a gas leak, immediately close

LP cylinder valve and call LP gas supplier or your fire department!

10

Leak Testing Valves, Hose and Regulator

1.Turn all grill control knobs to OFF.

2.Be sure regulator is tightly connected to LP cylinder.

3.Completely open LP cylinder valve by turning hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately. There is a major leak at the connection. Correct before proceeding.

4.Brush soapy solution onto areas circled below, or other similar fittings on your grill.

 

 

 

 

 

 

 

 

NOTE: Your grill

 

 

NOTE: Sideburner

 

may NOT be

 

 

shelf fascia not

 

equipped with a

 

 

shown for clarity.

 

sideburner.

 

 

 

 

 

 

5.If “growing” bubbles appear, there is a leak. Close LP cylinder valve immediately and retighten connections. If leaks

cannot be stopped do not try to repair. Call for replacement

parts.

6.Always close LP cylinder valve after performing leak test by turning hand wheel clockwise.

Page 9 Page 11
Image 10
Page 9 Page 11
Contents Product Guide Date PurchasedTable of Contents This Grill is for Outdoor USE onlyInstallation Safety Precautions California PropositionLava Rock / Briquettes Temperature Convective Grills onlyFirst Time Use Pre-Heating Your GrillIndirect Cooking Food SafetyDirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures Routine Care Why Clean? General Cleaning Storing Your GrillLP Cylinder Filling USE and CareLP Liquefied Petroleum Gas UL listed Overfill ProtectionLP Cylinder Leak Test For your safetyNipple has to be centered into the LP cylinder valve Connection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Injury Safety TipsFor Safe Use of Your Grill and to Avoid Serious Use grill at least 3 ft. from any wall or surfaceSear Burner Match-Lighting Ignitor LightingSear Burner Ignitor Lighting Sideburner Ignitor LightingTurning Grill Off General Grill CleaningBurner Flame Check Ignitor CheckVery Important Burner tubes must reengage valve Cleaning the Burner AssemblyStoring Your Grill Turn gas OFF at control knobs and LP cylinderLimited Warranty Items Manufacturer will not PAY forKey Qty Description Parts ListQty Description Not PicturedParts Diagram Machine Screw Qty Flange Nut Assembly20x2-3/8 #8x3/8 Sheet Metal Screws QtyMetal Tab ScrewsFlange Nut Qty 20x2-3/8 Machine Screw 20x2 Machine Screw Weight Block 20x2 Machine Screw QtyFlange Nut Qty Right side panel removed for clarity 20x1/2 Screw QtyScrew Lock Washer Qty 7mm Fiber Washer 20x1/2Qty 20x1/2 7mm Screw Qty 20x1/2 Screw Flange Nut 7mm 20x1/2 Screw20x1/2 Machine Screw QtySideburner Bezel Sideburner Valve Sideburner Control Knob Ignitor WireSideburner Valve Venturi Clip #8-32x3/8#8 Wing nut Sideburner Tube5mm Flat Washer Qty Left Door 5mm Lock Washer QtyBack Pin Warming Rack Leg Wire Pivot Wire Cooking Grate AA BatterySear Burner LP Cylinder Not included Heat ShieldGrease Tray Tank Retainer ScrewEmergencies Possible Cause Prevention/Solution TroubleshootingProblem Problem Possible Cause Prevention/Solution Possible Cause Prevention/SolutionTroubleshooting Electronic Ignition SectionMail to / Enviar a / Envoyer à Special Offer
Top Page Image Contents