Pride Mobility 1121 owner manual B a T T E R I E S a N D C H a R G I N G, Batteries and Charging

Page 28

V I . B A T T E R I E S A N D C H A R G I N G

BATTERIES AND CHARGING

The power chair uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) level. Deep-cycle batteries are designed to handle a longer and deeper discharge. Though they are similar in appearance to automotive batteries, they are not interchangeable. Automotive batteries are not designed to handle a long, deep discharge, and also are unsafe for use in power chairs.

WARNING! Battery posts, terminals, and related accessories contain lead and lead compounds. Wash hands after handling.

WARNING! Prevent injury and/or equipment damage! Do not use batteries that exceed the recommended type and amp-hour capacity. Do not use batteries with different amp-hour capacities. Refer to specifications table in this manual and in the manual suppled with the battery charger for recommended type and capacities.

Charging the Batteries

The battery charger is essential in providing long life for your power chair batteries. It is designed to optimize your power chair’s performance by charging the batteries safely, quickly, and easily. The battery charging system consists of the battery charger, the charger circuit fuse, and the ammeter (optional onboard chargers only). The ammeter indicates the rate of charge necessary to fully recharge the batteries. It is also a good indication of whether or not the charger is working. The ammeter and the charger are only functional when the charger power cord is plugged into an electrical outlet.

PROHIBITED! Removal of grounding prong can create electrical hazard. If necessary, properly install an approved 3-pronged adapter to an electrical outlet having 2-pronged plug access. Failure to heed could result in personal injury and/or property damage.

PROHIBITED! Never use an extension cord to plug in your battery charger. Plug the charger directly into a properly wired standard electrical outlet.

WARNING! You must recharge your power chair’s batteries with the supplied off-board or optional onboard battery charger. Do not use an automotive-type battery charger.

WARNING! Prevent injury and/or equipment damage! Read the battery charging instructions in this manual and in the manual supplied with the battery charger before charging the batteries.

WARNING! Prevent injury and/or equipment damage! Do not expose the off-board battery charger to rain or other sources of moisture unless it has been tested for outdoor use. Refer to the manual supplied with the battery charger for more information.

WARNING! Prevent injury and/or equipment damage! Explosive gases may be generated while charging the batteries. Keep the power chair and battery charger away from sources of ignition such as flames or sparks and provide adequate ventilation when charging the batteries.

WARNING! Prevent injury and/or equipment damage! Inspect the battery charger, wiring, and connectors for damage before each use. Contact your Quantum Rehab Specialist if damage is found.

WARNING! Prevent injury and/or equipment damage! Do not attempt to open the battery charger case. If the battery charger does not appear to be working correctly, contact your Quantum Rehab Specialist.

WARNING! Prevent injury and/or equipment damage! If the off-board battery charger is equipped with cooling slots, then do not attempt to insert objects through these slots.

WARNING! Prevent injury and/or equipment damage! Do not allow unsupervised children to play near the power chair while the batteries are charging.

28

www.quantumrehab.com

Quantum1121

Page 27 Page 29
Image 28
Page 27 Page 29
Contents Page F E T Y G U I D E L I N E S N T E N T S IIISafety N T R O D U C T I O NPURCHASER’S Agreement Information ExchangePride Owners Club My Quantum Rehab SpecialistS a F E T Y Pre-Ride Safety CheckModifications Tire Inflation Weight LimitationsIncline Information Cornering Information Braking InformationOutdoor Driving Surfaces Stationary Obstacles Steps, Curbs, etc Freewheel ModePublic Streets and Roadways Stairs and Escalators Transfers DoorsElevators Lift/Elevation ProductsInclement Weather Precautions Motor Vehicle TransportPositioning Belts Reaching and BendingBatteries AlcoholElectromagnetic and Radio Frequency Interference EMI/RFI I . Y O U R P O W E R C H a I R QuantumSpecifications Quantum 1121 Power Base Electronics Tray Active-Trac SuspensionManual Freewheel Lever To operate the dual manual freewheel leversSeat Installation Initial AssemblyA S S E M B L Y To install the seat Comfort Adjustments Seat Height and Seat Angle AdjustmentO M F O R T a D J U S T M E N T S To change the seat heightSeat Position Adjustment Manual Recline Seatback AdjustmentSeatback Angle Adjustment Armrest Width AdjustmentArmrest Height Adjustment ArmrestAngle AdjustmentFoot Platform Height Adjustment Foot Platform Depth AdjustmentSwing-away Footrests Foot Platform Angle AdjustmentElevating Leg Rests To adjust the anti-tip wheels Anti-Tip WheelsPower Elevating Seat Option Power Elevating Seat ActuatorTo operate the power elevating seat Power Elevating Seat OperationTo use the swivel feature Batteries and Charging B a T T E R I E S a N D C H a R G I N GCharging the Batteries To charge the batteries using the off-board charger To charge the batteries using the optional onboard chargerBattery Break-in To break in new batteries for maximum efficiencyFrequently Asked Questions FAQs Why do my new batteries seem weak? How can I ensure maximum battery life?How should I store my power chair and its batteries? What type of batteries should I use?I . O P E R a T I O N VSI Electronic ControllerVSI consists JoystickBattery Condition Meter On/Off KeyRed lights only lit or slow flash Charge batteries as soon Speed/Profile KeysActuator Connector Controller ConnectorCharger Inhibit Connector Actuator Keys and Actuator Lights For Optional EquipmentVSI Error Codes Thermal RollbackRemote Plus Controller Remote Plus Master RemoteMode Key Speed Setting IndicatorPower Accessory Indicator Right/Left Turn Indicator KeysSpeed Settings To select a speed settingPower Accessories Power ModuleActuator Lighting Module Not Shown Sleep ModeRemote Plus Trouble Codes Microdrive Controller Microdrive Controller consistsProfile and Speed Indicator Actuator IndicatorDisplay Pad Joystick Interface ModuleTo select a profile setting Speed AdjustmentError Codes Drive Profile SelectionFlashing Lights Diagnosis Solution Care and Maintenance Should your power chair come in contact with waterTemperature I I . C a R E a N D M a I N T E N a N C EDaily Checks Weekly ChecksTo check the brakes Monthly ChecksDisposal of Your Power Chair Cleaning InstructionsWheel Replacement StorageBattery Replacement Battery Wiring Diagram LabelCorrective Maintenance When to See Your Quantum Rehab Specialist for ServiceTo replace the batteries W a R R a N T Y Reconditioned Units Warranty Warranty ExclusionsService Checks and Warranty Service Exclusions also include components with damage caused byQuality Control Quantum
Top Page Image Contents