Epson D55168 instruction manual Voltage and Circuit Protection, Compatibility Location, Moving

Page 11

Voltage and Circuit Protection

Refer to the Voltage and Minimum Branch Circuit Requirements under Pump/Motor Specifications.

CAUTION: Certain air compressors can be operated on a 15 amp circuit if the following conditions are met.

•Voltage supply to circuit must comply with the National Electrical Code.

•Circuit is not used to supply any other electrical needs.

•Extension cords comply with specifications.

•Circuit is equipped with a 15 amp circuit breaker or 15 amp time delay fuse. NOTE: If compressor is connected to a cir- cuit protected by fuses, use only time delay fuses. Time delay fuses should be marked “D” in Canada and “T” in the US.

If any of the above conditions cannot be met, or if operation of the compressor repeatedly causes interruption of the power, it may be necessary to operate it from a 20 amp circuit. It is not necessary to change the cord set.

Compatibility

NOTE: Always use an air line filter to remove moisture and oil vapor when spraying paint.

Location

Place the air compressor in a clean, dry and well ventilated area at least 12" (30.5 cm) away from the wall or other obstructions that will interfere with the flow of air. Keep the compressor away from areas that have dirt and/or volatile fumes in the atmosphere. These impurities may clog the intake filter and valves, causing inefficient operation.

WARNING: The air compressor pump and shroud are designed to allow for proper cooling. The ventilation openings on the com- pressor are necessary to maintain proper operating temperature.

Do not place rags or other containers on or near these openings.

Place the air compressor on a flat surface resting on the rubber feet and wheels.

ELECTRICAL

Refer to all safety instructions before using unit. Observe extension cord safety instructions if necessary. Always move the On/Auto/Off switch (A) to the OFF position before removing the plug from the outlet.

TRANSPORTING

When transporting the compressor in a vehicle, trailer, etc., make sure the tank is drained and the unit is secured with straps to prevent tipping. Use care when driving to prevent tipping the unit over in the vehicle. Damage can occur to the compressor or surrounding items if the compressor is tipped.

LIFTING

Always use two people when lifting and lift from the recommended lift points (N). DO NOT lift by wheels or shroud.

MOVING

N

 

CAUTION: The wheels and handle do not

 

provide adequate clearance, stability, or sup-

 

port for pulling the unit up and down stairs or

N

steps. The unit must be lifted or pushed up a

 

ramp.

 

1. Grasp handle of compressor and tilt com- pressor back to rest on wheels.

WARNING: Risk of Unsafe Operation. Ensure proper footing and use caution when rolling compressor so that unit does not tip or cause loss of balance.

English

11

Page 10 Page 12
Image 11
Page 10 Page 12
Contents D55168 Declared Noise Emission Values per ISO D55168 Air CompressorPump/Motor Specifications SpecificationsDewalt Definitions Safety GuidelinesImportant Safety Instructions Save These InstructionOr explosion With the product when it isUnit when not in use If electrical sparks fromCorrect tire pressure What can Happen HOW to Prevent ITAttachments & accessories English To repair compressor with When fatigued or underNever defeat the safety fea Attempting to operatePressure Switch For Future USE FeaturesON/AUTO/OFF Switch Place this switch a ON/AUTOAIR Compressor Pump Safety ValveCheck Valve Drain Valve Cooling SystemExtension Cords InstallationAssembly Grounding InstructionsMoving Voltage and Circuit ProtectionCompatibility Location Initial Set-up Fig Pre-Start Checklist FigOperating Procedures Preparation for USEShut-down Fig MaintenanceMaintenance Chart Procedure Daily Weekly Monthly Year orChecking Air Filter Element Fig Checking Safety ValveAccessories Draining Air Tank FigDate and Place of Purchase Service InformationFull One Year Warranty RepairsGlossary Code Possible Cause Possible Solution Troubleshooting GuideTroubleshooting Codes Problem CodeExplode Compressor on its own branch circuit Check for proper fuse. You should use a time delay fuseFiche technique Compresseur d’air, modèle D55168Fiche technique de la pompe/du moteur Ce qui peut se produire Définitions lignes directrices en Matière de sécuritéDirectives de sécurité importantes Conserver CES DirectivesCE QUI Peut SE Produire Avertissement Risque D’ÉCLATEMENT Comment L’ÉVITERAvertissement Risque DE Choc Électrique AccessoiresAvertissement Risque Provenant DES Objets Projetés EN L’AIR Avertissement Attention Surfaces ChaudesAvertissement Risque Associé À Utilisation Dangereuse Avertissement Risque Associé AUX Pièces MobilesManocontacteur Mise EN Garde Risque Associé AU BruitAvertissement Risque DE Chute Interrupteur MARCHE/AUTO/ARRÊTClapet Soupape DE SûretéCorp DE Branchement Rapide Universel Robinet DE PurgeRaccordement DES Tuyaux AssemblageDirectives relatives à la mise à la terre Protecteur DE Surcharge DU MoteurCompatibilité EmplacementRallonges Protection de la tension et du circuitÉlectricité Mode D’EMPLOIDéplacement Liste de vérification de pré-démarrage FigProcédure DE Rodage Réglage initial FigProcédures DE Fonctionnement Démarrage Fig Procédure Quoti Hebdo Mensuelle Arrêt FigEntretien Programme d’entretienVérification des éléments du filtre d’air Fig Vérification de la soupape de sûretéVidange du réservoir d’air Fig Garantie complète d’un 1 an AccessoiresInformation sur les réparations RéparationsGlossaire Problème Code Code Cause Probable Solution ProbableGuide de dépannage Codes de dépannageOu un centre de réparation agréé Dewalt De l’accessoireJoints d’étanchéité fuyants Lire l’avertissement concernant les vapeurs inflammables Consulter la rubrique Surcharge du moteur sousLa pression du réservoir excède la pression Possibilité d’un moteurCourroie usée Filtre d’admission d’air obstrué Code Cause ProbableValores de emisión de ruido declarados según ISO Compresor de aire D55168Especificaciones de la Bomba y el Motor Especificaciones¿QUÉ Puede SUCEDER? Instrucciones de seguridad importantesGuarde Estas Instrucciones Peligro Riesgo Respiratorio Asfixia Elementos y accesorios Advertencia Riesgo DE ExplosiónCómo Evitarlo Advertencia Riesgo DE Descarga EléctricaVer la presión correcta del neumático Advertencia Riesgo DE Superficies Calientes Advertencia Riesgo DE Objetos DespedidosAdvertencia Riesgo DE Operación Insegura Advertencia Riesgo POR Piezas MóvilesPrecaución Riesgo POR Ruidos Conserve Estas Instrucciones Para Futuras ConsultasCaracterísticas Instrucciones de conexión a tierra InstalaciónEnsamblaje Debe usar Cables prolongadoresVoltaje y protección del circuito Unidad tiene una pata a tierra L. Este EnchufeTransporte CompatibilidadLugar EléctricasProcedimiento DE Puesta EN Marcha Inicial Preparación Para EL USOLista de control previa a la puesta en marcha Fig Configuración inicial FigMantenimiento Procedimientos Operativos Puesta en marcha FigApagado Fig Procedimiento Diaria Semanal Mensual Vez al Tabla de mantenimientoControlar la válvula de seguridad Drenar el tanque de aire FigReparaciones Controlar el elemento del filtro de aireAccesorios Información DEL Servicio TécnicoReemplazogratuitodelasetiquetasdeadvertencia Garantía completa de un añoGlosario Código Causa Posible Solución Posible Guía de detección de problemasCódigos de detección de problemas Problema CódigoVálvula aún pierde, debe ser reemplazada Sellos de pérdidasCentro de servicio autorizado Dewalt Válvula de seguridad defectuosaInflamable Posible motor defectuososCentro de servicio autorizado D Ewalt Page MAY07 Form No D55168 Copyright 2007 D Ewalt Ewalt Industrial Tool Co., 701 Joppa Road, Baltimore, MD

D55168 specifications

The Epson D55168 is a cutting-edge printer designed specifically for high-performance printing needs, catering to both professional and personal usage. Known for its reliability and efficiency, this model showcases a blend of innovative features and advanced technologies that make it a preferred choice for many users.

One of the standout features of the Epson D55168 is its PrecisionCore technology, which ensures high-quality prints at astounding speeds. This tech utilizes a micro-electromechanical system (MEMS) to create ultra-fine droplets of ink, leading to sharp text and vibrant images. This printer is capable of delivering crisp black and white prints, as well as vivid colors that can bring life to any document or image.

Another notable characteristic of the D55168 is its superior paper handling capabilities. With a robust input tray that can accommodate various media types and sizes, users can easily switch between printing tasks without the need for constant adjustments. This versatility makes it an ideal choice for offices where different formats, such as envelopes, labels, and photo paper, are often required.

In terms of connectivity, the Epson D55168 excels with multiple options available for users. It boasts USB, Ethernet, and wireless connectivity, allowing seamless integration into various network environments. This flexibility enables remote printing capabilities from smartphones, tablets, and laptops, making it convenient for users to print from virtually anywhere in the office or home.

Furthermore, the printer is designed with energy efficiency in mind. Epson’s eco-friendly ink technology not only delivers outstanding print quality but also reduces the environmental impact. The D55168 utilizes replaceable ink cartridges that are designed for high yield, minimizing waste and maximizing efficiency. With a user-friendly interface and thoughtful design, the printer ensures a smooth user experience while maintaining a commitment to sustainability.

Overall, the Epson D55168 embodies a combination of innovative printing technologies, exceptional performance, and user-friendly features. It stands as a reliable choice for those seeking a high-quality, efficient printing solution capable of meeting diverse printing needs, whether in a professional setting or at home.
Top Page Image Contents