Epson D55168 Shut-down Fig, Maintenance Chart, Procedure Daily Weekly Monthly Year or

Page 13

CAUTION: Risk of unsafe operation. Compressed air from the unit may contain water condensation and oil mist. Do not spray unfil- tered air at an item that could be damaged by moisture. Some air operated tools or devices may require filtered air. Read the instruc- tions for the air tool or device.

3.Adjust regulator (D) to desired setting. See Regulator under Features.

Shut-down (Fig. 1)

1.Move On/Auto/Off switch (A) to the OFF position. NOTE: If finished using compressor, follow Steps 2 - 6.

NOTE: When the unit has been turned off, it is normal to hear a short hiss of air being released.

2.Pull the regulator knob (D) out and turn counterclockwise until fully closed. Ensure regulated pressure gauge reads 0 PSI. Push knob in to lock in place.

3.Remove hose and accessory.

WARNING: Risk of unsafe operation. Firmly grasp air hose in hand when installing or disconnecting to prevent hose whip.

4.Drain the air tank, see Draining Air Tank under Maintenance. Ensure air tank pressure gauge reads 0 PSI.

WARNING: Risk of bursting. Drain air tank daily. Water will condense in air tank. If not drained, water will corrode and weaken the air tank causing a risk of air tank rupture.

5.Allow the compressor to cool down.

6.Wipe air compressor clean and store in a safe, non-freezing area.

MAINTENANCE

The following procedures must be followed when maintenance or service is performed on the air compressor.

1. Ensure On/Auto/Off switch is in the OFF position.

2.Remove air compressor plug from outlet.

3.Drain air tank.

4.Allow air compressor to cool down before starting service. NOTE: All compressed air systems contain maintenance parts (e.g., oil, filters, separators) that are periodically replaced. These used parts may contain substances that are regulated and must be disposed of in accordance with local, state, and federal laws and regulations. NOTE: Take note of the positions and locations of parts during disassembly to make reassembly easier.

NOTE: Any service operations not included in this section should be performed by a DEWALT factory service center or a DEWALT authorized service center.

Maintenance Chart

Procedure

Daily

Weekly

Monthly

1 year or

 

 

 

 

200 Hours

 

 

 

 

 

Check safety valve

X

 

 

 

Inspect air filter

 

X

 

 

 

 

 

 

 

Drain air tank

X

 

 

 

 

 

 

 

 

Check for unusual noise/

X

 

 

 

vibration

 

 

 

 

 

 

 

Check for air leaks*

X

 

 

 

Clean compressor exterior

 

X

 

 

* To check for air leaks apply a solution of soapy water around joints. While compressor is pumping to pressure and after pressure cuts out, look for air bubbles to form.

English

13

Page 12 Page 14
Image 13
Page 12 Page 14
Contents D55168 Pump/Motor Specifications D55168 Air CompressorSpecifications Declared Noise Emission Values per ISOImportant Safety Instructions Definitions Safety GuidelinesSave These Instruction DewaltUnit when not in use With the product when it isIf electrical sparks from Or explosionAttachments & accessories What can Happen HOW to Prevent ITCorrect tire pressure English Never defeat the safety fea When fatigued or underAttempting to operate To repair compressor withON/AUTO/OFF Switch For Future USE FeaturesPlace this switch a ON/AUTO Pressure SwitchCheck Valve Drain Valve Safety ValveCooling System AIR Compressor PumpAssembly InstallationGrounding Instructions Extension CordsCompatibility Location Voltage and Circuit ProtectionMoving Operating Procedures Pre-Start Checklist FigPreparation for USE Initial Set-up FigMaintenance Chart MaintenanceProcedure Daily Weekly Monthly Year or Shut-down FigAccessories Checking Safety ValveDraining Air Tank Fig Checking Air Filter Element FigFull One Year Warranty Service InformationRepairs Date and Place of PurchaseGlossary Troubleshooting Codes Troubleshooting GuideProblem Code Code Possible Cause Possible SolutionExplode Compressor on its own branch circuit Check for proper fuse. You should use a time delay fuseFiche technique de la pompe/du moteur Compresseur d’air, modèle D55168Fiche technique Directives de sécurité importantes Définitions lignes directrices en Matière de sécuritéConserver CES Directives Ce qui peut se produireCE QUI Peut SE Produire Avertissement Risque D’ÉCLATEMENT Comment L’ÉVITERAvertissement Risque DE Choc Électrique AccessoiresAvertissement Risque Provenant DES Objets Projetés EN L’AIR Avertissement Attention Surfaces ChaudesAvertissement Risque Associé À Utilisation Dangereuse Avertissement Risque Associé AUX Pièces MobilesAvertissement Risque DE Chute Mise EN Garde Risque Associé AU BruitInterrupteur MARCHE/AUTO/ARRÊT ManocontacteurCorp DE Branchement Rapide Universel Soupape DE SûretéRobinet DE Purge ClapetDirectives relatives à la mise à la terre AssemblageProtecteur DE Surcharge DU Moteur Raccordement DES TuyauxRallonges EmplacementProtection de la tension et du circuit CompatibilitéDéplacement Mode D’EMPLOIListe de vérification de pré-démarrage Fig ÉlectricitéProcédures DE Fonctionnement Démarrage Fig Réglage initial FigProcédure DE Rodage Entretien Arrêt FigProgramme d’entretien Procédure Quoti Hebdo MensuelleVidange du réservoir d’air Fig Vérification de la soupape de sûretéVérification des éléments du filtre d’air Fig Information sur les réparations AccessoiresRéparations Garantie complète d’un 1 anGlossaire Guide de dépannage Code Cause Probable Solution ProbableCodes de dépannage Problème CodeJoints d’étanchéité fuyants De l’accessoireOu un centre de réparation agréé Dewalt La pression du réservoir excède la pression Consulter la rubrique Surcharge du moteur sousPossibilité d’un moteur Lire l’avertissement concernant les vapeurs inflammablesCourroie usée Filtre d’admission d’air obstrué Code Cause ProbableEspecificaciones de la Bomba y el Motor Compresor de aire D55168Especificaciones Valores de emisión de ruido declarados según ISOGuarde Estas Instrucciones Instrucciones de seguridad importantes¿QUÉ Puede SUCEDER? Peligro Riesgo Respiratorio Asfixia Elementos y accesorios Advertencia Riesgo DE ExplosiónVer la presión correcta del neumático Advertencia Riesgo DE Descarga EléctricaCómo Evitarlo Advertencia Riesgo DE Superficies Calientes Advertencia Riesgo DE Objetos DespedidosAdvertencia Riesgo DE Operación Insegura Advertencia Riesgo POR Piezas MóvilesPrecaución Riesgo POR Ruidos Conserve Estas Instrucciones Para Futuras ConsultasCaracterísticas Ensamblaje InstalaciónInstrucciones de conexión a tierra Voltaje y protección del circuito Cables prolongadoresUnidad tiene una pata a tierra L. Este Enchufe Debe usarLugar CompatibilidadEléctricas TransporteLista de control previa a la puesta en marcha Fig Preparación Para EL USOConfiguración inicial Fig Procedimiento DE Puesta EN Marcha InicialApagado Fig Procedimientos Operativos Puesta en marcha FigMantenimiento Controlar la válvula de seguridad Tabla de mantenimientoDrenar el tanque de aire Fig Procedimiento Diaria Semanal Mensual Vez alAccesorios Controlar el elemento del filtro de aireInformación DEL Servicio Técnico ReparacionesReemplazogratuitodelasetiquetasdeadvertencia Garantía completa de un añoGlosario Códigos de detección de problemas Guía de detección de problemasProblema Código Código Causa Posible Solución PosibleCentro de servicio autorizado Dewalt Sellos de pérdidasVálvula de seguridad defectuosa Válvula aún pierde, debe ser reemplazadaInflamable Posible motor defectuososCentro de servicio autorizado D Ewalt Page MAY07 Form No D55168 Copyright 2007 D Ewalt Ewalt Industrial Tool Co., 701 Joppa Road, Baltimore, MD

D55168 specifications

The Epson D55168 is a cutting-edge printer designed specifically for high-performance printing needs, catering to both professional and personal usage. Known for its reliability and efficiency, this model showcases a blend of innovative features and advanced technologies that make it a preferred choice for many users.

One of the standout features of the Epson D55168 is its PrecisionCore technology, which ensures high-quality prints at astounding speeds. This tech utilizes a micro-electromechanical system (MEMS) to create ultra-fine droplets of ink, leading to sharp text and vibrant images. This printer is capable of delivering crisp black and white prints, as well as vivid colors that can bring life to any document or image.

Another notable characteristic of the D55168 is its superior paper handling capabilities. With a robust input tray that can accommodate various media types and sizes, users can easily switch between printing tasks without the need for constant adjustments. This versatility makes it an ideal choice for offices where different formats, such as envelopes, labels, and photo paper, are often required.

In terms of connectivity, the Epson D55168 excels with multiple options available for users. It boasts USB, Ethernet, and wireless connectivity, allowing seamless integration into various network environments. This flexibility enables remote printing capabilities from smartphones, tablets, and laptops, making it convenient for users to print from virtually anywhere in the office or home.

Furthermore, the printer is designed with energy efficiency in mind. Epson’s eco-friendly ink technology not only delivers outstanding print quality but also reduces the environmental impact. The D55168 utilizes replaceable ink cartridges that are designed for high yield, minimizing waste and maximizing efficiency. With a user-friendly interface and thoughtful design, the printer ensures a smooth user experience while maintaining a commitment to sustainability.

Overall, the Epson D55168 embodies a combination of innovative printing technologies, exceptional performance, and user-friendly features. It stands as a reliable choice for those seeking a high-quality, efficient printing solution capable of meeting diverse printing needs, whether in a professional setting or at home.
Top Page Image Contents