Subaru Robin Power Products PKV101 manual G B G B G B

When warranty repair is needed, the engine must be brought to an authorized service dealer or warranty station’s place of business during normal business hours . In all cases, a reasonable time, not to exceed 30 days, must be allowed for the warranty repair to be completed after the engine is received by the authorized service dealer or warranty station.

G . MAINT E NANC E , R E P L AC E ME NT	AND
R E P AIR OF E MIS S ION-R E L AT E D	P AR T S

Only warranted engine replacement parts approved by F UJ I should be used in the performance of any warranty maintenance or repairs on emission-related parts . If other than authorized parts are used for maintenance, replacement or repair of components affecting emission control, you should assure yourself that such parts are warranted by their manufacturer to be equivalent to authorized parts in performance and durability. F UJ I ,however, assumes no liability under this warranty with respect to parts other than authorized parts . T he use of non- authorized replacement parts does not invalidate the warranty on other components unless the non-authorized parts cause damage to warranted parts .

US

I. MAINT E NANC E S T AT E ME NT S

H. P AR TS C OVE R E D UNDE R THE C AL IF OR NIA E MIS S IONS WAR R ANTY

(1) F uel Metering S ystem

(i) C arburetor and internal parts

(ii)Air cleaner plate (including choke system)

(iii)Air cleaner cover

(iv)Air cleaner element

(v)F uel F ilter

(2)Ignition S ystem

(i)S park plug

(ii)F lywheel magneto

(iii)Ignition coil

(3)Miscellaneous Items Used in Above S ystems

(i)Hoses and sealing gaskets, bolts, connectors, and assemblies .

It is your responsibility to have all scheduled inspection and maintenance services performed at the times recommended in the 2000 and later Owner's Manual and to retain proof that inspection and maintenance services are performed at the times when recommended. F UJ I will not deny a warranty claim solely because you have no record of maintenance; however, F UJ I may deny a warranty claim if your failure to perform required maintenance resulted in the failure of warranted part. T he proof which you maintain should be given to each subsequent owner of the engine. Y ou are responsible for performing the scheduled maintenance described below based on the procedures specified in the 2004 and later Owner's Manual. T he scheduled maintenance below is based on a normal engine operating schedule.

GB G B G B G B

P R OC E DUR E		INT E R VAL
1)	C lean engine and check bolts and nuts . R etighten if necessary.	: E very 8 hours (daily)
2)	C heck and refill engine oil (4 stroke)	: E very 8 hours (refill daily up to upper limit)
3)	C hange engine oil (4 stroke)	: Initial 20 hours and every 100 hours afterward
4)	C heck clogging of cooling air passage and cylinder fins .	: E very 8 hours (daily)
	R emove and clean if necessary.
5)	C lean air cleaner	: E very 8 hours (daily)
6)	C heck spark plug. C lean and adjust if necessary.	: E very 8 hours (daily)
7)	C heck muffler exhaust outlet (or port). C lean if necessary.	: E very 50 hours (monthly)
8)	C heck fuel filter. If clogged, replace with new one.	: E very 50 hours (monthly)
9)	Adjust valve clearance, if applicable (4 stroke)	: E very 200 hours
10)	R eplace fule lines .	: E very 200 hours
11)	Overhaul engine.	: E very 200 hours
12)	R eplace packings and gaskets with new ones .	: E very reassembling

Note: More frequent maintenance may be necessary under dusty, dirty or severe conditions .

G B