Napoleon Fireplaces BGD90NT, BGD90PT manual Remote and Valve Access

Page 19

19

REMOTE AND VALVE ACCESS

The control area can be accessed either through the control door or through the access panel inside the fi rebox.

INNER ACCESS PANEL

Follow the door removal instructions. Remove the right side panel. Remove the four screws from the access door.

Note: A new gasket will be required, when re-installing the access panel (see replacement parts).

REMOTE RECEIVER REMOVAL

1.Open the right control door by pulling bottom portion away from magnet catch.

2.Remove the hearth strip by lifting up and away from unit.

3.Remove the receiver by pulling the left side of the plate away from the bracket.

4.Once disengaged pull the wiring harness out from the back of receiver.

CONTROL MODULE REMOVAL

1.Remove access panel from inside the fi rebox.

2.Unplug the control module from the junction box

3.Pull up on the control module being held down with velcro and disconnect the plugs (fan, aux). Remove wiring harness from the front of casing.

VALVE REMOVAL

The valve on The is piped with two flex connec- tors

(one inlet, one outlet).

It can be removed or pulled forward for service.

1.Open right control door.

2.Remove the wing nut and pivot the valve out from the slot at the bottom of the valve.

3.Slowly pull the valve through the control door being careful not to kink the gas lines or wires.

“AUTO SPARK” BATTERY REMOVAL

1.Open the right control door by pulling bottom portion away from magnet catch.

2.Remove the hearth strip by lifting up and away from unit.

3.The spark module is located in the front right corner of the unit (see photo below).

4.Disengage the battery compartment door from the top of module.

5.Replace battery and re-install compartment door.

4.Install the new control module (see schematic Pg.14).

WING NUT

VALVE

SLOT

RECEIVER

SPARK MODULE

WING NUT

VALVE

SLOT

RECEIVER

SPARK MODULE

FIGURE 38

W415-0614 / A / 07.24.07

Page 18 Page 20
Image 19
Page 18 Page 20
Contents Installation Table of Contents Napoleon GAS Fireplace PRESIDENT’S Lifetime Limited Warranty Vent pipe Inches General InstructionsGeneral Information To stand-offs top, rear and sidesCare of GLASS, and Plated Parts VentingVenting Lengths & AIR Terminal Locations Definitions TOP Exit / Horizontal TerminationElbow Vent Length Values = 2 ft = 4 ft= 1.5 ft = V1 + V2 = 4 + 1.5 = 5.5 ftTOP Vertical Termination TOP Exit Vertical TerminationAIR Terminal Installations See figure15 Installation Wall and Ceiling ProtectionVertical Installation Horizontal InstallationUse only approved aluminum flexible liner kits marked Using Flexible Vent ComponentsHorizontal AIR Terminal Installation Vertical AIR Terminal InstallationRestricting Vertical Vents Mobile Home InstallationClearance to Combustibles Framing22 3/8 to top of fireplace opening Electrical Connection Hard Wiring ConnectionAccess panel must be re-installed before operating the unit It is necessary to hard wire this fireplaceLOG Shipping Bracket GLASS/DOOR ReplacementFinishing Door RemovalInstall Panels in the Following Order Brick Panel InstallationLOG Placement Andiron PlacementGlowing Embers Night Light ReplacementCharcoal Embers VermiculiteRemote and Valve Access Hand Held Remote Operations Operation / MaintenanceTime OUT Fireplace OperationFAN Speed Setting Address Setting Procedure DIP Switch Number 0 = on / 1 = OFF What to do if YOU Smell GAS For Your Safety Read Before LightingOperating Instructions Lighting InstructionsMaintenance AdjustmentsFuel Conversion Check Pressure Readings Fig Pilot Burner AdjustmentFlame Characteristics Venturi AdjustmentReplacements 000 Symptom Problem Test Solution Trouble Shooting GuideCheck that the wire is connected to the spark module Fireplace Service History W415-0614 / a
Related manuals
Manual 32 pages 38.75 Kb

BGD90PT, BGD90NT specifications

The Napoleon Fireplaces BGD90PT and BGD90NT represent the pinnacle of modern fireplace design, combining cutting-edge technology with timeless aesthetics. These models are specifically crafted for those who value both warmth and style in their living spaces.

One of the standout features of the BGD90PT and BGD90NT is their large viewing area, which allows an unobstructed view of the flames, creating a mesmerizing focal point in any room. The expansive glass front enhances the ambiance of the fire, making it feel more immersive and inviting. This sleek design not only provides aesthetic benefits but also improves heat distribution, contributing to the overall efficiency of the fireplace.

The BGD90PT (Propane) and BGD90NT (Natural Gas) models utilize a range of advanced technologies to enhance performance. The patented PHAZER® technology creates a beautiful and realistic flame effect, while the variable speed blower and adjustable heat output allow for customized comfort levels. This precise control ensures that users can maintain the perfect temperature, regardless of outside conditions.

Furthermore, these models are engineered with Napoleon's exclusive TOP-VENT technology, which provides flexible venting options for easy installation. This feature allows homeowners to maximize their living space and choose the venting configuration that best suits their home’s layout.

The BGD90PT and BGD90NT also prioritize safety and efficiency. Both models are equipped with an electronic ignition system that provides reliable start-up, eliminating the hassle of traditional pilot lights. Additionally, the fireplaces include a built-in safety barrier to prevent accidental contact with the glass, making them suitable for homes with children and pets.

With their impressive heat output, the BGD90PT and BGD90NT can efficiently warm larger spaces, contributing to the overall comfort of your home. Their Energy Star rating ensures that they meet the highest standards for energy efficiency, making them an eco-friendly choice.

In terms of design, both models feature a contemporary look that complements various interior styles. From rustic to modern aesthetics, the BGD90PT and BGD90NT can enhance any home décor while providing the warmth and ambiance of a traditional fireplace.

In conclusion, the Napoleon Fireplaces BGD90PT and BGD90NT are an exceptional fusion of design, technology, and efficiency. Their impressive features make them an ideal choice for anyone looking to add a touch of elegance and functionality to their space, all while enjoying the comforting warmth of a beautiful fire.
Top Page Image Contents