Jotul operating instructions General Maintenance Gaskets, Gasket List for the F 3 CB

Page 17

4.Remove all remaining debris from the glass area using a wire brush.

5.Apply a small bead of gasket/stove cement and the new gasket. Do not overlap the ends of the gasket rope.

6.Center the new glass panel over the gasket and

reinstall the glass clips. See figure 17. IMPORTANT: The side of the glass treated with an

infrared coating (marked on the perimeter) should always be facing outward. It is extremely impor- tant to tighten the glass clips slowly and in a repeating pattern, like tightening the lugs on an automobile wheel.

7.It may be necessary to retighten the glass clips after the stove has be burned and the gasketing has been seated.

door

gasket

glass

FIGURE17

glass clips

General Maintenance

Gaskets

Check door and window gaskets for tightness. To check the seal of the front doors, close and latch the doors on a dollar bill and slowly try to pull the dollar bill free. If it can be easily removed then the seal is too loose. Check several spots around the door, and repeat the procedure on the ash pan door as well.

If gaskets need to be replaced, scrape out the old gasket and cement and clean the area with a wire brush. Apply a small bead of cement and push in the new gasket. After closing and latching the doors wipe clean, any excessive cement that has come from beneath the gasketing.

GASKET LIST FOR THE F 3 CB

Description

Order #

Size

Length

Top Plate Gasket

100038

3/8” LD

5'6”

Ash Housing Gasket

128213

sheet gasket

 

Ash Door Gasket

200024

¼” LD

3'

Glass Gasket

200028

3/16” LD

3’6”

Door Gasket

200024

1/4” LD

5'

Air manifold Gasket

200028

3/16”

16”

Like your car, regular maintenance prolongs the life of your appliance. The following procedures do not take long and are generally inexpensive, but when done consistently, increase the life of your appliance and in turn, increase your years of enjoyment.

At least once a year you should perform the following maintenance procedures:

Thoroughly clean the stove. Enamel surfaces should be cleaned with soap and water.

Empty stove of all soot and ashes. Only use a vacuum for this job if the vacuum is specifically designed for ashes.

Inspect the stove; using a strong light inspect the stove inside and out for cracks or leaks. Replace all cracked parts and repair any cement leaks with furnace cement.

The F 3 CB is designed to burn cleanly and efficiently when used according to the guidelines expressed in these operating instructions. However, to maintain the proper performance, a yearly chimney inspection and cleaning in necessary. Failure to keep the chimney system free of creosote and build up could result in a serious chimney fire.

17

Page 16 Page 18
Image 17
Page 16 Page 18
Contents Jøtul F 3 CB Woodstove Table of Contents Jøtul F 3 CB Woodstove StandardsF 3 CB wood stove has been tested and listed to Reminder InstallationSide Exit Venting Do not use the connector pipe as a chimneyMasonry Chimneys Chimney RequirementsWall PASS-THROUGHS Chimney HeightU.S Common MethodCanada Connecting to the ChimneySee .3.1 and 5.3.2 of CAN/CSA B365-M91 Masonry ChimneySee figures 10 Hearth-mount into a Masonry FireplacePrefabricated Chimneys Clearances to Combustibles Using Shields to Reduce ClearancesFloor Protection U.S.and CanadaSide Rear Corner Connector Unprotected Surface Protected Surface ClearancesStove Clearances Unprotected Surfaces Mantel ClearancesWall Shields for Close Clearance Alcove ceiling above top of stove = 40 1015mm AlcoveHeight above the top of the stove = 40 1015mm Do Not Burn OperationCoal Treated or painted wood Garbage Controls on the F 3 CBAdding Fuel Cool the stove to room temperatureFormation of Creosote MaintenanceGlass Care Rinse and dry glass completely, before burning your stoveGasket List for the F 3 CB General Maintenance GasketsFloor Bracket Kit AccessoriesTHEF3 ExplodedCB Parts List Jøtul ASA

F 3 specifications

The Jotul F 3 is a classic wood stove that embodies the perfect blend of traditional design and modern engineering. Renowned for its efficiency and durability, this model has become a favorite among homeowners looking for an effective heating solution with aesthetic appeal.

One of the standout features of the Jotul F 3 is its efficient combustion system. This stove employs a unique primary and secondary combustion system that allows for a cleaner burn, producing minimal emissions. This technology not only enhances the stove's efficiency but also contributes to a reduced environmental footprint, making it an excellent choice for eco-conscious consumers.

In terms of design, the Jotul F 3 is crafted from cast iron, a material known for its longevity and heat retention properties. This construction allows the stove to radiate warmth long after the fire has died down, providing consistent heating throughout the day and evening. The stove is available in several finishes, including classic black and a striking blue-black enamel, enabling it to seamlessly fit into various interior styles, from rustic to contemporary.

The Jotul F 3 also includes a large glass window that offers an unobstructed view of the flames, enhancing the cozy ambiance of any room. The airwash system keeps the glass clean, ensuring a clear view of the fire while minimizing the need for frequent cleaning.

With a heating capacity of up to 1,800 square feet, the Jotul F 3 is ideal for both small and medium-sized spaces. Its compact size does not compromise on performance, and it features a sizable firebox that allows for extended burn times, meaning less frequent refueling.

Another notable characteristic of the Jotul F 3 is its user-friendly design. The stove includes easy-to-use controls for adjusting the airflow, allowing users to optimize the burn rate and heat output based on their preferences.

In conclusion, the Jotul F 3 is a versatile and efficient wood stove that combines classic aesthetics with modern technology. Its high combustion efficiency, durable cast iron construction, and elegant design make it a sought-after choice for anyone seeking warmth and beauty in their home. With its commitment to both functionality and style, the Jotul F 3 stands out as an exemplary heating solution that will serve homeowners for years to come.
Top Page Image Contents