GN National Electric PV-28SV50, PV-28SV55, GN, BP)-1, CP Parts List, Index Part Number Description

Page 42

PARTS LIST

PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide.

Index

Part

 

Number

Number

Description

 

 

 

1

22868

REAR PANEL ASSEMBLY

2

21654

BRACKET, PIPE ASSEMBLY

3

22670

REAR HEAT SHIELD ASSEMBLY

4

21664

TOP COVER ASSEMBLY (INCLUDES #5)

5

R8854

BALL STUD

6

22693

TOP HEAT SHIELD ASSEMBLY

7

22859

FIREBOX ASSEMBLY (INCLUDES #9 & #26)

8

22860

HEAT EXCHANGER TUBE ASSEMBLY (INCLUDES 3 OF #9)

9

R8855

GASKET, END PLATE

10

22861

PLATE, RESTRICTOR ASSEMBLY (INCLUDES 2 OF #9)

11

22862

INDUCER ASSEMBLY (INCLUDES #12 & #14)

12

22863

BLOWER ASSEMBLY (INCLUDES #14)

13

R8802

SWITCH, BIMETALIC

14

R8795

GASKET, SUMP

15

22864

HEAT EXCHANGER ASSEMBLY (INCLUDES 2 OF #9, MUST ORDER #14)

16

R8811

GASKET, INLET HEADER

17

21650

TUBING (SUMP TO PUMP)

18

21652

TUBING (SUMP TO PRESSURE SWITCH)

19

21627

SHIELD, REAR INNER

20

22779

LEFT REAR PANEL ASSEMBLY (INCLUDES INSULATION)

21

21667

LEFT SIDE DOOR ASSEMBLY

22

22642

TUBE, CONDENSATE

23

21647

CONNECTOR TUBING ASSEMBLY (PUMP TO CONDENSATE TUBE)

24

21605

COVER, INLET AIR DUCT

25

22780

INLET AIR DUCT ASSEMBLY

26

R8810

GASKET, INLET AIR DUCT

27

21641

BRACKET ASSEMBLY THERMISTER (SPRING CLIP INCLUDED)

28

R4053

CLAMP, DOOR (4 USED ON UNIT)

29

22694

BRACKET, MAGNET HOLDER ASSEMBLY (2 USED ON UNIT)

30

21640

BRACKET ASSEMBLY (SPRING CLIP INCLUDED)

31

21615

ANGLE, HEAT EXCHANGER BRACKET

32

21609

ANGLE, REAR HEAT SHIELD BRACKET

33

22668

RIGHT REAR PANEL ASSEMBLY (INCLUDES INSULATION)

34

21665

RIGHT SIDE DOOR ASSEMBLY

35

21651

TUBING (FIREBOX TO PRESSURE SWITCH)

36

R8835

FITTING, BARBED HOSE

37

22865

IGNITOR, HOT SURFACE ASSEMBLY

38

21611

BRACKET, IGNITOR

39

R8807

FLAME SENSOR

40

22656

LOG PLATE ASSEMBLY

41

22657

SMALL BURNER ASSEMBLY NAT (INCLUDES #43 AND #44)

41

22753

SMALL BURNER ASSEMBLY LPG (INCLUDES #44)

42

22658

LARGE BURNER ASSEMBLY (INCLUDES #44))

43

R8791

BUSHING, AIR SHUTTER (NAT ONLY)

44

R8790

BUSHING, BURNER

45

P208

REAR ORIFICE, LPG

45

P294

REAR ORIFICE, NAT

46

P293

FRONT ORIFICE, NAT

46

P295

FRONT ORIFICE, LPG

47

R8793

HOLDER, ORIFICE

48

R7572

JAMB NUT

49

22627

GAS LINE - REAR

Page 42

22618-4-1106

Image 42
Contents Installation Instructions Table of Contents Important Safety Information This is a Heating ApplianceSafety Information for Users of LP-GAS LP-GAS Warning OdorRequirements for Massachusetts Vent Directly BELOW. Keep Clear of ALL ObstructionsGAS Supply Installing a New Main Gas CockPressure Testing of the Gas Supply System Recommended Gas Pipe DiameterIntroduction Specifications AccessoriesClearances for Direct Vent Heater Installation for Direct VentInstallation on Rugs and Tile Locating Wall OpeningHeater Installation for Single Flue Clearances for Single FlueHeater with Pedestal and Single Flue Adaptor Specifications Heater without PedestalFireplace Insert with Mantel surround with slim top panel Flue Outlet Electric Cord 8 BSP Connection Inside SurroundFireplace Insert with Mantel Surround with short top panel Clearance to Combustibles Freestanding UnitsLOG SET Installation Instructions Log InstallationAll Logs LOG SET Diagram a Installation Instructions General Safety Information Vent Examples for Single Flue Vent Examples for Single Flue Single Flue Vertical Vent RunFlex Vent Tubing Venting for Existing Fireplace Installation Determining Minimum Vent Height Above the RoofHorizontal Venting Direct Vent Installation InstructionsDirect Vent System Building Exterior View Maximum Horizontal Venting 47 1/2 1.2mMinimum Exterior Grade Dimension Unit Without Pedestal Minimum Exterior Grade Dimension Unit With PedestalDirect Vent Installation Instructions GAS Connection Installation Instructions GAS Connection Line SupplyOperating Instructions Checklist Lighting Instructions For Your Safety Read Before Lighting FAN Operation GAS Conversion Instructions Conversion Instructions from LP Propane GAS to Natural GASConversion Instructions from Natural GAS to LP Propane GAS Automatic Humidifier Operation Optional Remote Control Thermostat Thermostat Display ModeWiring Wiring DiagramGeneral Information MaintenanceOver Temperature Cut Out Paint Curing First FiringMain Burner Drawing Cleaning Main Burner Front door removal drawing Glass CleaningGlass Assembly Replacement General Glass InformationUnit Operating Faults Resetting the HeaterLOG Placement Main Convection FANHeat Exchanger Surround Installation Instructions Parts ListPedestal Installation Instructions Optional Pedestal Assembly InstallationParts List Index Part Number DescriptionGAS Line Front Parts View 7368 Warranty Terms Purchase Date Dealer Name/PhoneHOW to Order Repair Parts Service Notes