Wayne-Dalton 9700 installation instructions Table of Contents

Page 2

Table of Contents

 

Important Safety Instructions

......................................................... 2

Package Contents

3

Door Section Identification

4

Tools Required

5

Removing An Existing Door

5

Preparing The Opening

6

Installation

7-23

Optional Installations

24-28

Cleaning

29

Painting Instructions

29-30

Warranty

31

Dealer Locator Information

32

Definition of key words used in this manual:

WARNING

Indicates a potentially hazardous situation which, if not avoided, could result in severe or fatal injury.

IMPORTANT: Required step for safe and proper door operation.

NOTE: Information assuring proper installation of the door.

WARNING

To avoid possible injury, Read these instructions carefully before attempting installation. If in question about any of the procedures, do not perform the work. Instead, have a trained door systems technician do the installation or repairs.

1.Read and follow all installation instructions.

2.Wear protective gloves during installation to avoid possible cuts from sharp metal edges.

3.It is always recommended to wear eye protection when using tools, otherwise severe or fatal eye injury could result.

4.Avoid installing your new door on windy days. Door could fall during the installation causing severe or fatal injury become entrapped between the door and the floor.

5.Doors 12’-0” wide and over should be installed by two persons, to avoid possible injury.

6.Operate door ONLY when it is properly adjusted and free from obstructions.

7.If a door becomes hard to operate, inoperative or is damaged, immediately have necessary adjustments and/or repairs made by a trained door system technician using proper tools and instructions.

8.DO NOT stand or walk under a moving door, or permit anybody to stand or walk under an electrically operated door.

9.DO NOT place fingers or hands into open section joints when closing a door. Use lift handles/gripping points when operating door manually.

10.DO NOT permit children to operate garage door or door controls.

11.Due to constant extreme spring tension, DO NOT attempt any adjustment, repair or alteration to any part of the door, especially to springs, spring brackets, bottom corner brackets, red colored fasteners, cables or supports. To avoid possible severe or fatal injury, have any such work performed

by a trained door systems technician using proper tools and instructions.

12.On electrically operated doors, pull down ropes must be removed and locks must be removed or made inoperative in the open (unlocked) position.

13.Top section of door may need to be reinforced when attaching an electric opener. Check door and/or opener manufacturer’s instructions.

14.VISUALLY inspect door and hardware monthly for worn and or broken parts. Check to ensure door operates freely.

15.Test electric opener’s safety features monthly, following opener manufacturer’s instructions.

16.NEVER hang tools, bicycles, hoses, clothing or anything else from horizontal tracks. Track systems are not intended or designed to support extra weight.

After installation is complete, fasten this manual near garage door.

2Please Do Not Return This Product To The Store. Contact your local Wayne-Dalton dealer. To find your local Wayne-Dalton dealer, refer to your

local yellow pages business listings or go to the Find a Dealer section online at www.Wayne-Dalton.com

Page 1 Page 3
Image 2
Page 1 Page 3
Contents 9700 Important NoticeTable of Contents Package Contents Labels on each end stile Each section except top sectionUsed to identify each section EndstileTools Required Removing An Existing DoorBackroom requirement Preparing the OpeningHeadroom requirement Track Type MIN. HeadroomTracks InstallationQuick Install TAB Unlocked Flagangle Vertical TrackTools Needed Hammer Installing Jamb BracketsHorizontal Angles Tools Needed None DrumsBottom Section Stacking Sections Vertical Track Assembly Jamb Bracket Bottom SectionVertical Tracks Flagangle CableBar Self Tapping ScrewsOperator Bracket Roller Top BracketsTop Section TOP Bracket SlideHorizontal Track Tion Causing Severe or FatalFlagangles Truss Head BoltTools Needed Wrench Step Ladder Adjusting Top BracketsTorqueMaster Spring Tube Center Bracket Bushing Center Bracket AssemblyCenter Bracket Bushing Cable Drums/ Drum Wraps 2 WrapsWrench Socket Driver Step Ladder Securing Center Bracket AssemblyEnd Brackets Ratchet wheel is required on the leftTools Needed Vice Clamps Cable AdjustmentSecuring Door For Spring Winding Leather gloves be worn while Winding SpringsIt is recommended that Winding the TorqueMasterTurns on TorqueMaster Plus end bracket Securing Drum WrapsImportant Mark number of spring Result in door falling Rear SupportRaising door further can Cause severe or fatal injuryWheel from the Recommended Spring Turn ChartFull Tension of the Spring Number of Turns Shown onTorqueMaster Plus Reset InstructionsBalancing Door TorqueMaster Plus Reset InstructionsChecking Springs for Tension PawlPawl knob in Lower Position Place vice clamps Above 3rd Roller on both vertical trackAttached to Track Pawl knob in upper PositionAs shown Pull RopeJamb approximately 48 to 50 1220 to No Scew EYE Pull Rope Bottom BracketMAY Result in Severe or Fatal Injury Trolley OperatorFailure to Test or Make ANY Painting CleaningAcrylic Cleaning Instructions Important do not USE a Pressure Washer on Your Garage DoorPainting Lifetime Limited Warranty Model YouThank you for your purchase
Related manuals
Manual 2 pages 15.21 Kb Manual 18 pages 29.29 Kb Manual 4 pages 60.02 Kb Manual 2 pages 14.43 Kb

9700 specifications

Wayne-Dalton is a well-known brand in the garage door industry, offering a wide range of models designed for durability, performance, and aesthetic appeal. Among its most popular series are the 9700, 5000, 8000, 9000, and 9800, each equipped with unique features and advanced technologies to meet diverse customer needs.

The Wayne-Dalton 9700 series is known for its combination of strength and insulation. This garage door is manufactured with a three-layer construction providing robust protection against the elements while offering excellent energy efficiency. The insulated steel construction can help maintain interior temperatures, making it ideal for attached garages.

The 5000 series, on the other hand, is designed for a more traditional look combined with modern performance. Featuring a lightweight design, it is made from durable materials that resist rust and corrosion. The 5000 series can be customized with different colors and styles, allowing homeowners to achieve the perfect aesthetic to enhance their property.

Moving on to the 8000 series, this model is designed for commercial applications and residential use where heavy-duty functions are necessary. It is built to withstand extreme weather conditions while providing optimal security with added strength features. The 8000 series offers smooth operation and minimal maintenance requirements, making it a great choice for those seeking reliability.

The 9000 series stands out with its stylish design and sleek finishes. This series offers advanced insulation options, coupled with numerous panel designs that provide a polished and sophisticated look. The 9000 model emphasizes both aesthetics and energy efficiency, making it a favorite among homeowners looking for a beautiful yet functional garage door.

Lastly, the 9800 series is the premium option within Wayne-Dalton’s offerings. This series is characterized by its high insulation value and thermal efficiency, thanks to its innovative construction techniques. The 9800 doors can be customized with numerous panel options and colors, delivering a luxury look while ensuring excellent performance.

In conclusion, Wayne-Dalton’s 9700, 5000, 8000, 9000, and 9800 series garage doors each feature distinctive characteristics and technologies aimed at enhancing durability, security, and aesthetics. Homeowners can find a reliable option within this range that suits their specific requirements, whether they prioritize insulation, style, or heavy-duty functionality. With Wayne-Dalton’s commitment to quality and innovation, these garage doors stand out in today’s market.
Top Page Image Contents