![](/images/new-backgrounds/1048096/4809697x1.webp)
|
|
|
|
|
|
| Service Manual |
|
| |||
|
|
|
|
|
|
|
|
|
|
|
|
|
3 Troubleshooting (continued) |
|
|
|
|
|
|
|
|
|
| ||
|
|
|
| |||||||||
|
|
|
| |||||||||
Table 3F (continued from previous page) Troubleshooting Chart - Fault Messages Displayed on Boiler Interface |
|
| ||||||||||
|
|
|
|
|
|
|
| |||||
FAULT | DESCRIPTION |
| CORRECTIVE ACTION |
|
|
| ||||||
|
|
|
|
| ||||||||
|
|
| • If 24 VAC is present at the main control board, check |
| ||||||||
|
|
| the wiring between the main control board and the gas |
| ||||||||
|
|
| valve. Replace the wiring if necessary. Do not |
| ||||||||
|
|
| disconnect the wiring from the gas valve and attempt |
| ||||||||
|
|
| to measure voltage at that point. The main control |
| ||||||||
|
|
| board can detect if the gas valve is not connected and |
| ||||||||
Flame Lost |
|
| will display the Gas Valve / Connection fault. |
|
|
| ||||||
|
| • If 24 VAC is present, check the outlet of the valve to |
| |||||||||
While Running |
|
|
| |||||||||
|
| ensure the valve is flowing gas. With a manometer |
| |||||||||
(cont’d) | The unit was running and lost the flame |
| ||||||||||
connected to the outlet tap of the gas valve, when the |
| |||||||||||
(will require a |
| |||||||||||
signal. This condition occurred twice . | unit is in | the prepurge | period, there | should be | a |
| ||||||
manual reset once the |
| |||||||||||
|
| negative | pressure present. | When | the | valve | is |
| ||||
condition has been |
|
|
| |||||||||
|
| energized a change in pressure should occur. If the |
| |||||||||
corrected. Press the |
|
|
| |||||||||
|
| pressure change does not occur, the gas valve is not |
| |||||||||
RESET button on the |
|
|
| |||||||||
|
| opening. Replace the gas valve. |
|
|
|
|
| |||||
display to reset.) |
|
|
|
|
|
|
| |||||
|
| • Inspect flame sensor and associated wiring. |
| |||||||||
|
|
|
| |||||||||
|
|
| Reference page 39 of this manual for removal and |
| ||||||||
|
|
| cleaning procedures. Replace if necessary. |
|
|
| ||||||
|
|
| • Inspect the burner. Reference page 39 of this manual |
| ||||||||
|
|
| for removal and cleaning procedures. Replace if |
| ||||||||
|
|
| necessary. |
|
|
|
|
|
|
| ||
|
|
| • Replace the main control board. |
|
|
|
|
| ||||
|
|
|
|
| ||||||||
|
|
| • Verify that the system is full of water and that all air |
| ||||||||
|
|
| has been properly purged from the system. |
|
|
| ||||||
|
|
| • Verify that the boiler is piped properly into the heating |
| ||||||||
|
|
| system. Refer to Section 6 - Hydronic Piping of the |
| ||||||||
|
|
| SYNC | Installation | and | Operation | Manual |
| ||||
|
|
| for the proper piping methods for the SYNC. |
|
|
| ||||||
|
|
| • Check voltage to boiler pump motor on a call for |
| ||||||||
Manual Reset |
|
| heat. If voltage is not present, check wiring back to |
| ||||||||
|
| the pump relay. |
|
|
|
|
|
|
| |||
High Limit |
|
| • Replace the pump relay if necessary. |
|
|
|
|
| ||||
(will require a |
|
|
|
|
|
|
| |||||
|
| • If 120 VAC is present on a call for heat and the boiler |
| |||||||||
manual reset once the | The outlet water temperature has exceeded |
| ||||||||||
condition has been | the setting of the high limit. | pump is not operating, replace the pump. |
|
|
| |||||||
corrected. Press the | • If the system pump is a variable speed pump, ensure |
| ||||||||||
|
|
| ||||||||||
RESET button on the |
|
| that the system flow is not less than the boiler flow. |
|
| |||||||
display to reset.) |
|
| • If operating on either an inlet or system supply |
| ||||||||
|
|
|
| |||||||||
|
|
| sensor, check temperature setting of the main control |
| ||||||||
|
|
| board. |
|
|
|
|
|
|
|
| |
|
|
| • If the high limit has tripped, check setting of the |
| ||||||||
|
|
| device. |
|
|
|
|
|
|
|
| |
|
|
| • Check resistance of water sensors and compare to |
| ||||||||
|
|
| Table 3B on page 45 of this manual. Replace sensor |
| ||||||||
|
|
| if necessary. |
|
|
|
|
|
|
| ||
|
|
| • Replace high limit. |
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| 49 |
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|