Goodman Mfg GPG13 Ignition Control Diagnostic Indicator Chart, Heating Timing Chart, Seconds

Page 19

IGNITION CONTROL DIAGNOSTIC INDICATOR CHART

Light Signal	Refer to Abnormal Heating or Cooling Operation Sections of this Manual
Off	Internal Control Failure
1 Flash	External Lockout
2 Flashes	Pressure Switch Stuck Open
3 Flashes	Pressure Switch Stuck Closed
4 Flashes	Thermal Protection Device Open
5 Flashes	Flame Detected with Gas Valve Closed
6 Flashes	Short Cycle Compressor Delay (Cooling Only)

HEATING TIMING CHART

Circulator

On

100 %

50 %

Blower

Off

Gas Valve On

Off

Igniter On

Induced

Off

Draft On

Blower Off

Thermostat On

Off

Seconds		0	15	22	45	52	0	29	120, 135,150
									180*PG1348,60 ONLY
Legend:	PG10,12,24-60, PG1324-42
	*PG1348,60

COOLING TIMING CHART

Circulator Blower

Outdoor Fan

and

Compressor

Thermostat

ON	100 %
OFF																										50 %

ON

OFF

ON

OFF


Seconds		0 7	30	0	60
Legend:	PG10,12,24-60, PG1324-42
	*PG1348,60

19

Image 19

Contents Ansi Z21.47CSA-2.3 Central Furnaces GPG13Index Safety Instructions Replacement PartsUnit Location Outside Slab InstallationRoof Curb Installation Rooftop InstallationGeneral Information Natural Gas Connection Rigging DetailsGAS Piping RiggingGAS Piping Checks Proper Piping PracticePropane Gas Pipe Sizing Low Voltage Wiring Electrical WiringTypical Propane Gas Piping Y2 C R Y1 W G Typical Thermostat and Unit 24 V Wiring HookupFilter Installation Duct Cover Installation Down Discharge ApplicationsCirculating AIR and Filters Condensate Drain VentingNormal Sequences of Operation Rollout Protection Control STARTUP, ADJUSTMENTS, and ChecksBe removed before operating unit Heat Anticipator Setting PG1348,60***1A onlyWhite-Rodgers 36G22 Gas Supply And Manifold Check With Power And Gas OffWith Power And Gas On White-Rodgers Model 36F22External Static Pressure Check Temperature Rise CheckBlower Speed Adjustments Main Burner Flame CheckTroubleshooting Internal Control Failure Pressure Switch Stuck Open Pressure Switch Stuck Closed Short Cycle Compressor DelayFlame Sensor MaintenanceBurner Flame Accessories and Functional PartsManifold Assembly Functional Parts ListCirculator Blower Ignition Control Diagnostic Indicator ChartHeating Timing Chart Cooling Timing ChartAppendix Unit Dimensions GPG1324,30,36,421A Wiring Diagram GPG1324,30,36,421A Wiring Diagram GPG13481A Wiring Diagram B4312004 Rev. a GPG13601A Wiring Diagram B4312005 Rev. a GPG13363A Wiring Diagram 0140G00085P Comp GPG1348,603A Wiring Diagram0140G00087 GND Comp GPG13364A Wiring Diagram0140G00088 GPG1348,604A Wiring Diagram 0140G00089 GPG1348,601B Wiring Diagram INSTALLER/SERVICEMAN Thermostat Field Wiring Recommended Filter Sizes Minimum ClearancesThis page Left Blank Intentionally This page Left Blank Intentionally Quality Makes the Difference That’s why we know. . .There’s No Better Quality