Multiquip QP4TE manual Fuel Safety

Page 9

FUEL SAFETY

DANGER

„DO NOT add fuel to equipment if it is placed inside truck bed with plastic liner. Possibility exists of explosion or fire due to static electricity.

„DO NOT start the engine near spilled fuel or combustible fluids. Fuel is extremely flammable and its vapors can cause an explosion if ignited.

„ALWAYS refuel in a well-ventilated area, away from sparks and open flames.

„ALWAYS use extreme caution when working with flammable liquids.

„DO NOT fill the fuel tank while the engine is running or hot.

„DO NOT overfill tank, since spilled fuel could ignite if it comes into contact with hot engine parts or sparks from the ignition system.

„Store fuel in appropriate containers, in well-ventilated areas and away from sparks and flames.

„NEVER use fuel as a cleaning agent.

„DO NOT smoke around or near the equipment. Fire or explosion could result from fuel vapors or if fuel is spilled on a hot engine.

SAFETY INFORMATION

BATTERY SAFETY (ELECTRIC START ONLY)

DANGER

„DO NOT drop the battery. There is a possibility that the battery will explode.

„DO NOT expose the battery to open flames, sparks, cigarettes, etc.The battery contains combustible gases and liquids. If these

gases and liquids come into contact with a flame or spark, an explosion could occur.

WARNING

„ALWAYS wear safety glasses when handling the battery to avoid eye irritation. The battery contains acids that can cause injury to the eyes and skin.

„Use well-insulated gloves when picking up the battery.

„ALWAYS keep the battery charged. If the battery is not charged, combustible gas will build up.

„DO NOT charge battery if frozen. Battery can explode. When frozen, warm the battery to at least 61°F (16°C).

„ALWAYS recharge the battery in a well-ventilated environment to avoid the risk of a dangerous concentration of combustible gases.

„ If the battery liquid (dilute sulfuric acid) comes into contact with clothing or skin, rinse skin or clothing immediately with plenty of water.

„If the battery liquid (dilute sulfuric acid) comes into contact with eyes, rinse eyes immediately with plenty of water and contact the nearest doctor or hospital to seek medical attention.

CAUTION

„ALWAYS disconnect the NEGATIVE battery terminal before performing service on the equipment.

„ALWAYS keep battery cables in good working condition. Repair or replace all worn cables.

OPERATION AND PARTS MANUAL — REV. #1 (10/10/08) PAGE 9

Page 8 Page 10
Image 9
Page 8 Page 10
Contents Model QP4TE Proposition 65 Warning Operation & Parts Manual REV. #0 01/25/06 Table of Contents Ordering parts has never been easier Parts Ordering ProceduresSafety Messages Safety InformationGeneral Safety Engine Safety Fuel Safety Transporting Safety Operation and Parts Manual REV. #1 10/10/08 Application General InformationSpecifications Pump Specifications Engine Specifications EngineUsed in general de-watering applications. Typical Pump ComponentsInitial Servicing Basic EngineInspection PRE-INSPECTION EngineBefore Starting PRE-SETUP PumpInitial START-UP Engine Normal Shutdown Initial START-UP EnginePump Vacuum Test Maintenance PumpPressure reading may vary Engine Maintenance Schedule Maintenance Engine24 -OPERATION and Parts Manual REV. #1 10/10/08 Pump Storage Preparation for Long -TERM StorageTroubleshooting Engine Troubleshooting ENGINE/PUMP Explanation of Code in Remarks Column QP4TE 1 to 5 Units with Suggested Spare PartsPump Assy Pump Assy 32 -OPERATION and Parts Manual REV. #1 10/10/08 Part Name QTY Remarks Robin EX270D50220 Engine AIR Cleaner Assy Base CP Robin EX270D50220 Engine Camshaft Assy PIN, CAMSHAFT, 9DX78.5L Robin EX270D50220 Engine Carburetor Assy Valve Throttle Robin EX270D50220 Engine Crankcase Assy Robin EX270D50220 Engine Crankcase Assy Robin EX270D50220 Engine CRANKSHAFT/PISTON Assy Crankshaft CP Robin EX270D50220 Engine Cylinder Head Assy Collet Valve Robin EX270D50220 Engine Fueltank Assy Part Name Robin EX270D50220 Engine Governor Assy Governor Lever Robin EX270D50220 Engine Ignition COIL/FLYWHEEL Assy Robin EX270D50220 Engine Ignition COIL/FLYWHEEL Assy Robin EX270D50220 Engine Muffler Assy Muffler CP Robin EX270D50220 Engine OIL Sensor Assy OIL Sensor CP Robin EX270D50220 Engine Recoil Starter Assy LABEL, Trade Mark 64D Terms and Conditions of Sale Parts Operation and Parts Manual REV. #1 10/10/08 HERE’S HOW to GET Help
Top Page Image Contents