Bosch Appliances GWH 425 PN/HN4GWH 4254, GWH 260 PN/HN2 manual Hot Cold

Page 25

Applications manual

25

 

 

3.2.4Bosch ProTankless gas water heater with domestic recirculation loop

The circulator should be controlled by an external aquastat, or with a timer to run only during times of expected hot water usage.

Hot

Cold

Ariston Pro GL4Ti (for pipe runs over 100ft use GL8Ti)

Bosch GWH 715 ES, Bosch GWH C 800 ES, Bosch GWH 425 HN or Bosch GWH 425 PN

Symbols

Potable water

Flow

expansion tank

check

 

valve

Bronze circulator sized according to UPC standards

(Taco Bronze 007 or Grundfos 15-42B will cover most homes up to 3 bathrooms)

Pressure

Sink

Standard

relief

 

tub

valve

 

fixture

Service

Timer or

 

Flow direction

valves

Aquastat

 

 

 

Note: Cold water piping to fixtures not shown for clarity purposes.

Note: This drawing is conceptual in nature and does not address all design, installation or safety considerations.

Additional safety and/or auxiliary equipment may be needed. This diagram is for reference use by officials, designers and licensed installers.

It is expected that installers have adequate knowledge of accepted industry practices for the equipment, procedures, and applications involved. Drawing is not to scale.

Drawing # WH2R

CN rev 06/07

Bosch Water Heating

Applications manual 11.2007

Image 25
Contents Applications manual Table of Contents Introduction Sizing tankless water heaters Sizing by ChartDefinitions Rule of thumb sizingGas Appliance Sizing Chart GWH 715 ES Installation Specifications FeaturesApplications manual GWH 715 ES Installation Clearances Installation guidelinesGWH C 800 ES Installation Clearances GWH C 800 ES Installation SpecificationsGWH C 800 ES Technical Specifications GWH C 800 ES Outdoor Installation for GWH 715 ESDescription Min Distances GWH 450 ESR Installation Clearances GWH 345 ESR Installation SpecificationsGWH 345 ESR Technical Specifications GWH 450 ESR Technical Specifications GWH 450 ESR Installation SpecificationsGWH 425 EF Installation Clearances GWH 425 EF Installation SpecificationsGWH 425 EF Technical Specifications GWH 425 HN Installation Clearances GWH 425 HN Installation SpecificationsGWH 425 HN Technical Specifications Establish a one-foot rise before any elbowsGWH 425 PN Installation Clearances GWH 425 PN Installation SpecificationsGWH 425 PN Technical Specifications GWH 260 PN Installation Specifications GWH 260 PN Installation ClearancesGWH 260 PN Technical Specifications Technical Specifications Maximum flow rate at given temperature riseElectrical requirements Powerstream Pro RP1P, RP2P, RP3P, RP7P, RP9P,RP12PT Ariston Pro GL2.5Ti, GL4Ti, GL8Ti Potable water Point-of-use applicationsIntroduction Service valve Temperature and pressureRelief valve SinkService valve Sink Flow direction Sink Service valves Low flow Flow direction Shower Temperature and pressure relief valvePowerstream Pro RP17PT or RP27PT Service Sink valvesPowerstream Pro whole house applications Standard tub fixtureHotCold Bosch ProTankless gas water heater SymbolsHot Cold Parallel unit applications Bosch GWH 715 ES Bosch GWH C 800 ES Pressure relief valvesGWH 715 ES and GWH C 800 ES cascading Cascading unit applicationsPressure Cold water Feed DHW Single unit tank loading application plumbing diagramBosch GWH 345 ESR Bosch GWH 450 ESR ESR control Board Single Unit Tank Loading Electrical DiagramCold water Radiant space heating and DHW plumbing diagramFeed External storage tankRadiant space heating and DHW electrical diagram Radiant Space Heating and DHW Electrical DiagramFan Coil Cold water Fan coil space heating and DHW plumbing diagramBosch GWH 345 ESR, Bosch GWH 450 ESR Fan Coil space heating and DHW electrical diagram Fan Coil Space Heating and DHW Electrical DiagramDrawing # BB OL RevA 10/07 Baseboard Space Heating and DHW Electrical Diagram Drawing # Bbaol RevA 10/07 Pkps Insulate piping Cold water feed Terminal box Back Flow preventer Baseboard Radiant PanelDrawing # EID Bbol CN revA 10/07 Descaling procedure Circulating pump Flow direction Filter Service valves Applications manual Applications manual Applications manual Applications manual BBT North America Corporation