Middleby Marshall PS640 installation manual III. Ventilation System, Requirements, Recommendations

Page 16

III. VENTILATION SYSTEM

IMPORTANT

Where national or local codes re- quire the installation of fire sup- pression equipment or other supplementary equipment, DO NOT mount the

equipment directly to the oven.

MOUNTING SUCH EQUIPMENT ON

THE OVEN MAY:

•VOID AGENCY CERTIFICATIONS

•RESTRICT SERVICE ACCESS

•LEAD TO INCREASED SERVICE EXPENSES FOR THE OWNER

A.Requirements

CAUTION: Gas oven installations REQUIRE a mechani- cally driven ventilation system with electrical exhaust air sensing control.

A mechanically driven ventilation system is STRONGLY RECOMMENDED for electric oven installations.

PROPER VENTILATION OF THE OVEN IS THE RESPONSI- BILITY OF THE OWNER.

B. Recommendations

NOTE THAT THE HOOD DIMENSIONS SHOWN IN FIGURE 2 - 5 ARE RECOMMENDATIONS ONLY . LOCAL, NATIONAL AND INTERNATIONAL CODES MUST BE FOLLOWED WHEN INSTALLING THE VENTILATION SYSTEM. ANY APPLICABLE CODES SUPERSEDE THE RECOMMENDATIONS SHOWN IN THIS MANUAL. IN AUSTRALIA COMPLIANCE TO REGULATIONS AS5601/AG601 IS MANDATORY.

The rate of air flow exhausted through the ventilation system may vary depending on the oven configuration and hood design. Consult the hood manufacturer or ventilation engineer for these specifications.

To avoid a negative pressure condition in the kitchen area, return air must be brought back to replenish the air that was exhausted. A negative pressure in the kitchen can cause heat- related problems to the oven components as if there were no ventilation at all. The best method of supplying return air is through the heating, ventilation and air conditioning (HVAC) system. Through the HVAC system, the air can be tempera- ture-controlled for summer and winter. Return air can also be brought in directly from outside the building, but detrimental effects can result from extreme seasonal hot and cold tempera- tures from the outdoors.

NOTE: Return air from the mechanically driven system must not blow at the opening of the baking chamber. Poor oven baking performance will result.

C. Other ventilation concerns

•Special locations, conditions, or problems may require the services of a ventilation engineer or specialist.

•Inadequate ventilation can inhibit oven performance.

•It is recommended that the ventilation system and duct work be checked at prevailing intervals as specified by the hood manufacturer and/or HVAC engineer or specialist.

Figure 2-5. Ventilation System

18″ (458mm)

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

minimum

2″ (51mm)

8″ (203mm)

 

 

 

 

 

 

 

 

3″ (76mm)

(Typical - both

 

 

 

 

 

 

 

 

ends of oven)

 

minimum

minimum

 

 

 

 

 

 

 

 

minimum

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

12

Page 15 Page 17
Image 16
Page 15 Page 17
Contents Owners Operating and Installation Manual Retain this Manual for Future Reference Middleby Marshall Table of Contents Description Oven UsesOven Specifications Triple OveInstallation Parts List for Series PS640 GAS Oven Installation KIT PS640 24″ Oven Installation Required Kits and EquipmentKit PS640 32″ Oven Installation Required Kits and Equipment ″ Legs Casters& Top Casters & Top Kit N61033 N59720 N59725Item no QTY Description Hardware BA G ″-16 × 1 HEX SCREW, SST Item no QTY Description Quad Outrigger Weldment A27727 83 -16x1-1/4 HEX Bolt A21924 III. Ventilation System RequirementsRecommendations Other ventilation concernsIV. Assembly Top Panel and Base Pad AssemblyRestraint Cable Installation StackingConveyor Installation Do not Overtighten the Conveyor BeltResetting Direction Jumper Switching Photo DetectorConveyor Belt Reversal Reversing the Conveyor BeltConnection VII. GAS SupplyAdjusting the Maximum Pressure Setting ConnectionGas Conversion PS640 Propane ConversionMaintenance Adjusting the Minimum Pressure SettingCheckout Location and Description of Controls II. Normal Operation STEP-BY-STEP III. Quick Reference Troubleshooting Screen AlertsMaintenance Maintenance DailyII. Maintenance Monthly Top Row Bottom RowIII. Maintenance Every 3 Months Split Belt Disassembly and CleaningIV. Maintenance Every 6 Months Blower BeltKEY Spare Parts PS640 GAS KEY Spare Parts Available separately. See FigureWiring Diagram Page Page

PS640 specifications

The Middleby Marshall PS640 is an industry-leading conveyor oven designed to meet the demands of commercial kitchens, particularly in pizza and other high-volume food applications. This oven combines advanced technologies with robust design, ensuring that users achieve consistent, high-quality results while optimizing operational efficiency.

One of the standout features of the PS640 is its unique design, which includes a patented jet impingement technology. This technology significantly enhances the cooking efficiency by using high-velocity hot air to cook food evenly and quickly. This not only reduces cooking times but also helps retain moisture and flavor, resulting in a superior product that delights customers.

Another key characteristic of the PS640 is its dual-mode operation. The oven can be configured for either high-speed cooking or traditional baking modes, making it versatile enough to handle a wide variety of menu items. This flexibility allows operators to maximize their kitchen space and adapt to changing customer demands effortlessly.

The PS640 also boasts a fully insulated cooking chamber, which ensures consistent cooking temperatures and minimizes energy loss. This thermal efficiency not only contributes to food quality but also helps reduce operational costs, making it an economically viable option for restaurants and foodservice operations.

Further enhancing its user-friendliness, the PS640 features an intuitive digital control panel. This allows staff to easily set cooking times and temperatures, monitor performance, and make adjustments as necessary. Additionally, the oven includes programmable cooking settings, making it easy to replicate popular dishes quickly and ensuring consistency across multiple shifts.

Durability is another hallmark of the PS640. Constructed with high-quality materials, this oven is built to withstand the rigors of a busy kitchen environment. Its stainless-steel exterior not only gives it a sleek look but also makes it easy to clean and maintain.

In summary, the Middleby Marshall PS640 is a state-of-the-art conveyor oven that excels in speed, efficiency, and versatility. Its advanced technologies, user-friendly features, and robust construction make it an ideal choice for foodservice operators looking to elevate their cooking capabilities and enhance their menu offerings. Whether for quick-service restaurants, pizzerias, or catering operations, the PS640 delivers outstanding results with every use, ensuring satisfied customers and a thriving business.
Top Page Image Contents