Maytag UMV1152CA Turntable Motor Removal, Vent Blower Removal, Disassembly Procedures, Blower ASM

Page 37

Turntable Motor Removal

Disassembly Procedures

!WARNING

To avoid risk of electrical shock, personal injury or death; disconnect power to microwave oven and discharge the high voltage capacitor before performing any disassembly procedures.

Turntable Motor Removal

1.Disconnect power to oven.

2.Remove screws securing bottom plate cover.

3.Open the oven door, remove turntable, and gently pry upward on turntable shaft.

4.Disconnect wire leads from turntable motor.

5.Remove screws securing turntable to the oven cavity.

6.Replace and reassemble in reverse order.

Vent Blower Removal

Vent blower is a five speed capacitor run blower assembly located on top of the oven. The blower is operated by voltage relays located on the circuit board.

Vent Exhaust Blower Removal

1.Disconnect power to unit and remove unit from its installation.

2.Remove screws securing damper and motor assembly to top and back of unit.

3.Remove damper.

4.Lift blower assembly out and disconnect wire connection wire terminal.

5.Reassemble in reverse order.

NOTE: Place blower assembly wires in slotted area to avoid pinching of wires.

Damper ASM

Blower ASM

© 2006 Maytag Services

16027303

37

Image 37

Contents UMV1152CA AMV1154BA AMV5164BA AMV5164BC AMV5206BA ServiceAMV6167BD MMV1153BA MMV4205BA MMV5165BA MMV5207BA MMV5207BC JMV8166BA JMV8208BA JMV8208BC JMV9169BACustomer Service Support Center Important Notices for Consumers and ServicersImportant Information DANGERTable of Contents Important Safety Information Procedure For Measuring Radiation Leakage Microwave Leakage TestingMeasurement With the Outer Panel Removed EquipmentPage Placement of the Oven SpecificationsService Parts and AccessoriesElectrical Requirements CleaningGrounding Instructions General InformationGeneral Information Microwave Oven DescriptionTroubleshooting Table Troubleshooting ProceduresTroubleshooting Procedures Checkout Procedure: FuseSymptom PROBLEMTroubleshooting Procedures Error Code Table16027303 Component Testing Procedures Testing ProceduresTest Procedure 16027303Test Procedure Testing ProceduresPower Level 16027303Test Procedure Testing Procedures16027303 IllustrationTesting Procedures Control Panel Sensor TestTest Procedure Test ProcedurePower Test Traditional Test Method Traditional Power Test Temperature ChartFahrenheit CelsiusTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentTest Procedure Testing Procedures16027303 ComponentDoor Assembly Removal Disassembly ProceduresDoor Disassembly Grille RemovalControl Panel Removal Printed Circuit Board RemovalDisassembly Procedures Control Panel/Switch Membrane DisassemblyControl Key Panel Removal Stirrer Assembly RemovalOuter Case Removal Disassembly ProceduresDisassembly Procedures Interlock Door Latch Switches RemovalInterlock Switch Removal Adjusting InterlocksDiode Removal High Voltage Capacitor RemovalMagnetron Removal Transformer RemovalMagnetron Thermal Fuse Removal Magnetron Fan Assembly RemovalHumidity Sensor Removal Select Models Oven Thermostat RemovalVent Blower Removal Turntable Motor RemovalDisassembly Procedures Blower ASMGrille Heater Element Removal Select Models Light Socket RemovalConvection Heater Element Removal Select Models Disassembly ProceduresAppendix A BEFORE YOU BEGIN Installation InstructionsREAD CAREFULLY. KEEP THESE INSTRUCTIONS Installation InstructionsStep-by-stepinstallation guide CONTENTSInstallation Instructions General informationELECTRICAL REQUIREMENTS IMPORTANT SAFETY INSTRUCTIONSInstallation Instructions Installation InstructionsOUTSIDE TOP EXHAUST EXAMPLE ONLY HOOD EXHAUSTOUTSIDE BACK EXHAUST EXAMPLE ONLY Installation InstructionsMaximum duct length Elbows, transitions, wall and roofExhaust connection Installation InstructionsPARTS INCLUDED DAMAGE – SHIPMENT/ INSTALLATIONHARDWARE PACKET ADDITIONAL PARTSMOUNTING SPACE TOOLS YOU WILL NEEDInstallation Instructions Installation InstructionsB.FINDING THE WALL STUDS 1.PLACEMENT OF THE MOUNTING PLATEInstallation Instructions Installation InstructionsInstallation Instructions Installation InstructionsPlate position – beneath flat bottom cabinet THE MICROWAVE MUST BE LEVELInstallation Instructions D.ALIGNING THE WALL PLATEInstallation Instructions NOTE: DO NOT MOUNT THE PLATE AT THIS TIMEA.RECIRCULATING NON-VENTEDDUCTLESS 2. INSTALLATION TYPES Choose A, B or CB.OUTSIDE TOP EXHAUST VERTICAL DUCT C.OUTSIDE BACK EXHAUST HORIZONTAL DUCTA.RECIRCULATING Non-VentedDuctless INSTALLATION OVERVIEWA1.ATTACH THE MOUNTING PLATE TO THE WALL To use toggle boltsInstallation Instructions A3.MOUNT THE MICROWAVE OVENInstallation Instructions B1.ATTACH THE MOUNTING PLATE TO THE WALL B.OUTSIDE TOP EXHAUST Vertical DuctInstallation Instructions Installation InstructionsInstallation Instructions Installation Instructions•Read the instructions on the TOP CABINET TEMPLATE Installation Instructions B5.MOUNT THE MICROWAVE OVENInstallation Instructions B7.CONNECTING DUCTWORK B6.ADJUST THE EXHAUST ADAPTORB5.MOUNT THE MICROWAVE OVEN cont Installation InstructionsC2.ATTACH THE MOUNTING PLATE TO THE WALL C.OUTSIDE BACK EXHAUST Horizontal DuctInstallation Instructions Installation InstructionsTO THE WALL cont C2.ATTACH THE MOUNTING PLATEFOR OUTSIDE BACK EXHAUST C3.USE TOP CABINET TEMPLATEInstallation Instructions C5.MOUNT THE MICROWAVE OVENInstallation Instructions Installation Instructions C5.MOUNT THE MICROWAVE OVEN contInstallation Instructions 16027303 Appendix BUse and Care 8VH &DUH*XLGHODEL *-6 2006 Maytag Services6%. 30%#&#!4/.3 HDWXUHVUse and Care %!2.2!/54 9/525 -#2/7!6%%/6% 2SHUDWLQJ,QVWUXFWLRQV#!54 #,/#+4,//&& #,$$,/#+$$$3%# 44-%2#//+. !44 0/7%2%,%6%,3 2SHUDWLQJ,QVWUXFWLRQV#//+. !44,/7%2 0/7%2%,%6%,3 #//+. 747 -/2%4!. /.% #//++#9#,%3%.3/2 /0%2!4. .3425#4/.3 2SHUDWLQJ,QVWUXFWLRQV3%.3/2 #//+. 5$% $$. /2 3542!#4. #//++4-%3%.3/2 #//+ +%$ 0/4!42%%!4 2SHUDWLQJ,QVWUXFWLRQV3%.3/2 2%%!444!,% 3%.3/2 #//++4!,%2SHUDWLQJ,QVWUXFWLRQV Use and Care54//#//++4!,% 54//#//+2SHUDWLQJ,QVWUXFWLRQV Use and Care$%&2/34. 5$% 54/ $%&2/34$%&2/34 2SHUDWLQJ,QVWUXFWLRQV3.!#+33#!24 3.!#+32SHUDWLQJ,QVWUXFWLRQV Use and Care3/&4%.-%,44#!24 3/&4%.-%,42SHUDWLQJ,QVWUXFWLRQV Use and Care#2/#/.6%#444!,% #2/#/.6%#42SHUDWLQJ,QVWUXFWLRQV Use and Care2SHUDWLQJ,QVWUXFWLRQV 54//2/, #//+Use and Care #!4%/29#/.6%#4/. 2!#+ #/.6%#4/. #//+2SHUDWLQJ,QVWUXFWLRQV Use and Care#/.6%#4/. !+. 74/54 02%%!4 #/.6%#4/. !+. 747 02%%!42SHUDWLQJ,QVWUXFWLRQV Use and Care2/,. 2!#+ 2/,,#//+54//2/, 4!,% 2SHUDWLQJ,QVWUXFWLRQV#/.6%#4/.2/,. 2!#+3$20 #!2% !.$ #,%#,%!.. 4% 2%!3%% &,4%2 #!546%. ,4 2%0,!#%-%.4 &DUHDQG&OHDQLQJ34%% #//+4/0.4,4, 2%0,!#%-%.4