Murray 461000x8A manual HOW to Replace Motion Drive Belt

Page 30

MAINTENANCE

HOW TO REPLACE

THE MOTION DRIVE BELT

REMOVAL

1.Remove the mower housing. See the instructions on “How To Remove The Mower Housing”.

2.Completely push the pedal forward and engage the parking brake.

3.Remove the idler pulleys (Figure 31).

Idler Pulley

Motion

Drive Belt

Drive Pulley

Idler Pulley

Figure 31

Shifter

Bracket

Shift Link

Hair

Pin

Figure 33

8.To remove the motion drive belt from the stack pulley, pull the front end of the belt under the stack pulley and then back between the stack pulley and the steering plate (Figure 34).

FRONT

Stack Pulley

Steering

 

 

Plate

Motion

Belt Guides

 

Drive

 

Belt

Figure 34

4.To access the belt guides, remove the battery and battery tray. See “How To Remove The Battery”.

5.Loosen the belt guides at the drive pulley (Figure 32).

Seat Spring

Belt Guide

Belt Guide

Figure 32

6.Remove the motion drive belt from the drive pulley (Figure 31).

7.Remove the hair pin from the shift link (Figure 33). Pull the motion drive belt over the shifter bracket.

9.Remove the access panel (Figure 35).

10.Remove the two screws that attach the steering shaft assembly (Figure 35). Raise the steering wheel and steering shaft assembly. Pull the motion drive belt under the steering shaft assembly.

Screw

 

 

Steering Shaft

 

 

Assembly

 

 

Motion Drive

 

 

Belt

Access Panel

Figure 35

 

11.Remove the motion drive belt. A correct replacement part or assistance is available from an Authorized Service Center in your area.

F–030718L

30

Image 30
Contents Model Table of Contents OWNER’S Information Environmental AwarenessSafe Operation Practices for Ride-on Mowers II. Slope operation Safe Mowing Guide Safe Mowing Guide Safe Mowing Guide Steps to Follow Before MowingInternational Pictorials Safety Warning PictorialsInternational Pictorials Control And Operating PictorialsAssembly Assembly100105417x47 HOW to Install the SeatHOW to Assemble the Steering Wheel 25x3 17x146HOW to Install the Battery Cables Maintenance Free BatteryHOW to Charge Maintenance Free Battery Remove the battery and battery trayIMPORTANT! Before YOU Start Mowing HOW to Prepare the EngineCheck the Level of the Mower Housing Check the TiresOperation Location of ControlsLift Lever Attachments HOW to USE the Throttle ControlHOW to USE the Shift Lever See the Instruction Book for the AttachmentHOW to Stop the Unit HOW to SET the Parking BrakeHOW to Change the Cutting Height HOW to Transport the UnitHOW to Operate with the Mower Housing HOW to Operate the Unit on HillsHOW to Start the Engine Before Starting the EngineCarburetor Operating Tips Mowing and Bagging TipsHOW to Change the Mulcher Plate How To Remove The Mulcher PlateHOW to Check the Muffler MaintenanceFrequency Maintenance Required Comments General RecommendationsInspect Blade HOW to Remove and Install the BladeHOW to Sharpen the Blade Mount the blade and blade adapter on the mandrelHOW to Adjust the Blade Rotation Control HOW to Check and Adjust the Motion Drive Belt HOW to Check and Adjust the Drive BrakeHOW to Adjust the Shift Lever Disconnect the red cable from the positive + terminalWhere to Lubricate HOW to Check the Fuel FilterRemove the mower drive belt from the stack pulley HOW to Remove the Mower HousingHOW to Install the Mower Housing Attach the extension spring to the blade control rod. SeeHOW to Adjust the Gauge Wheels Lift Lever Hole No Position No5,6 HOW to Level the Mower Housing HOW to Replace Motion Drive Belt Remove the motion drive belt from the drive pulley FigureInstallation Assemble the left pulley cover HOW to Replace the Primary Mower Drive BeltHOW to Replace the Secondary Mower Drive Belt Remove the primary mower drive belt from the stack pulleyHOW to Install the Wheels Fasten the rear wheel with washer and e-ringHOW to Clean the Mower Housing HOW to Replace the FuseHOW to Replace the Light Bulb BatteryTrouble Shooting Chart 030718L MURRAY, INC. Lawn Mower Central Parts Distributors 030718LSeat Deck Key Description Repair Parts Hood and DashRepair Parts Motion Drive Repair Parts Model 461000x8A Sector Gear Key Part DescriptionRepair Parts Front Axle Repair Parts Engine Mount Assembly Engine Mount Assembly Repair Parts Electrical System Electrical System Mower Housing Suspension Key Description Blade Drive This part is Included with Key Mower Housing Model 461000x8AREPAIR Parts Front Frame Assembly Repair Parts Rear Frame Assembly 030718L 030718L Index Model No Bushel Capacity