Craftsman YT 4500, 917.28990 manual Fuel System, Engine OiL, Cylinders, Other

Page 29

immediately prepare your tractor for stor- age at the end of the season or if the trac- tor wilt not be used for 30 days or more.

_WARNING: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing in any enclosure.

TRACTOR

When tractor is to be stored for a period

of time, clean it thoroughly, remove all dirt,

grease, leaves, etc. Store in a clean, dry area.

1.Clean entire tractor (See "CLEANING" in the Maintenance section of this manual).

2.Inspect and replace belts, if necessary (See belt replacement instructions in the Service and Adjustments section of this manual).

3.Lubricate as shown in the Maintenance section of this manual.

4.Be sure that all nuts, bolts and screws

are securely fastened. Inspect moving parts for damage, breakage and wear. Replace if necessary.

5.Touch up all rusted or chipped paint surfaces; sand lightly before painting.

BATTERY

*Fully charge the battery for storage.

*After a period of time in storage, battery may require recharging.

*To help prevent corrosion and power leakage during tong periods of storage, battery cables should be disconnected and battery cleaned thoroughly (see "TO CLEAN BATTERY AND TERMi- NALS" in the Maintenance section of this manual).

*After cleaning, leave cables disconnect- ed and place cables where they cannot come in contact with battery terminals.

*if battery is removed from tractor for storage, do not store battery directly on concrete or damp surfaces.

ENGINE

FUEL SYSTEM

IMPORTANT: It is important to prevent gum deposits from forming in essential

fuel system parts such as carburetor, fuel hose, or tank during storage. Also, alcohol blended fuels (called gasohol or using ethanol or methanol) can attract moisture

which leads to separation and formation of acids during storage. Acidic gas can dam- age the fuel system of an engine while in storage.

Empty the fuel tank by starting the en- gine and letting it run until the fuel lines and carburetor are empty.

Never use engine or carburetor cleaner products in the fuel tank or permanent damage may occur.

Use fresh fuel next season.

NOTE: Fuel stabilizer is an acceptable alternative in minimizing the formation of fuel gum deposits during storage. Add stabilizer to gasoline in fuel tank or stor- age container. Always follow the mix ratio found on stabilizer container. Run engine at least 10 minutes after adding stabilizer to allow the stabilizer to reach the car- buretor. Do not empty the gas tank and carburetor if using fuel stabilizer.

ENGINE OiL

Drain oil (with engine warm) and replace with clean engine oil. (See "ENGINE" in the Maintenance section of this manual).

CYLINDER(S)

1.Remove spark plug(s).

2.Pour one ounce of oil through spark plug hole(s) into cylinder(s).

3.Turn ignition key to start position for a few seconds to distribute oil.

4.Replace with new spark plug(s).

OTHER

•Do not store gasoline from one season to another.

•Replace your gasoline can if your can starts to rust. Rust and/or dirt in your gasoline will cause problems.

•if possible, store your tractor indoors

and cover it to give protection from dust and dirt.

•Cover your tractor with a suitable protective cover that does not retain moisture. Do not use plastic. Plastic cannot breathe which allows condensa-

tion to form and will cause your tractor to rust.

IMPORTANT: Never cover tractor while engine and exhaust areas are still warm.

29

Page 28 Page 30
Image 29
Page 28 Page 30
Contents Craftsman Sears, Roebuck and Co,, Noffman Estates, IL Craftsman Limited Warranty TWO Years on TractorDays on Battery General Operation IV. Towing Service Safe Handling of GasolineGeneralservice For prices and additional information call PRODUCTSPECIFiCATiONSSears Installation Service Keys MowerCheck Battery Tools Required for AssemblyAdjust Seat To Remove Tractor from Carton Unpack CartonAttach Mower Side Suspen First Install ANTI-SWAY BAR S10Turnsteeringwheeltopositionwheels Straightforward Check Tire Pressure ChecklistCheck Deck Levelness Check for Proper Position of ALL BeltsCruisecontrol @@@@@Service Reminder / Hour ME= Attachment Clutch SwitchKnow Your Tractor TractorTo USE Throttle Control D To SET Parking BrakeStopping To Adjust Mower Cutting Height System CharacteristicsTo Adjust Gauge Wheels To USE Cruise ControlTo Operate on Hills Using the Reverse Operation SystemTo Transport Towing Carts and Other AttachmentsADD Gasoline To Start EngineBefore Starting the Engine Mowing TiPS Purge TRANSMiSSiONChart Maintenance ScheduleGeneral Recommendations Before Each USEOperator Presence System TiresTransaxle Pump Fluid To Service CartridgeBelts To Change Engine OILIN=LINE Fuel Filter Clean AIR ScreenMuffler Deck Washout Port To Remove Mower Visual SIDE-TO-SIDE Adjustment To Install MowerPrecision SIDE-TO-SIDE Adjustment To Level MowerBelt Installation Mower Drive Belt InstallationTo Replace Mower Drive Belt Mower Drive Belt Removal To Replace Motion Drive BeltTo Remove Wheel for Repairs To Check BrakeTo Start Engine with a Weak BAT Tery To Attach Jumper CablesSembly Replacing BatteryEngine OiL Fuel SystemCylinders OtherCause Correction ProblemStart Hard toWhen Operator Loss of powerWill ExcessiveCutting Poor cut unevenMower blades will DischargeROS OFFSuggested Guide for Sighting Slopes for Safe Operation DOS Anos Para Tractores Pendientes FuncionamientoOperacjones DE Servicjo Generales IV. RemolqueServioio MANIPULACI6N Segura DE LA Gasoljna @@@@@ Responsabimdades DEL Cmente Especircaciones DEL ProductoDvertencia Acuerdos DE PROTECCI!N ParaLa segadora LlavesMonte Rueda Delatentera DE LA Para Hacer Rodar EL TractorDad y la funci6n de los controles DE Transmisjon Jnstale LA Segadora Y LA CorreaMontaje DE LA SE,GADORA Y DE LA COR- REA DE Transmision Fije LOS Brazos DE Suspension LATRealiceelmismoprocedimientoelotro ladodeltractor Revision DE LA Nivelacion DEL Conjunto REVISI6N DE LA Presion DE LAS LlantasRevision DE LA Posicion ADECUA= DA DE Todas LAS CorreasLacion ESTRANGU- R/PIDO LentoAtras Hacia Adelante Crucero DE Embrague Accesorio DEL FuegoPage IMPULSI6N DE Recorrido Parada Cuchillas DE LA SegadoraMotor Para Usar EL Control DE LA ACELER- ACI6N DCorte Para Ajustar LAS Ruedas CAUBRA- DorasPara Ajustar LA Altura DE Corte DE LA Segadora Para Operar LA SegadoraRemolque DE Carretillas O Otros Accesorios Para TransportarPara Operar EN Cerros CronometroArranque CON Tjempo Templado Para Hacer Arrancar EL MotorArranque CON Tiempo Frio Antes DE Hacer ArrancarConsejos Para Segar Calentamiento Para LA Transmision AutomaticaRgar LA Transmisjon Antes DE Cada USO Programade MantenimientoRecomendaciones Generales Operaoion DEL Freno TractorLlantas Vfrifiiz Sistema Presencia OperadorEnfriamiento DEL Transeje MotorNivel DEL Fluido DE LA Bomba DEL Transeje Para Cambiar EL Aceite DEL MotorLimpieza Filtro DE Combustible EN LineaLimpieza DE LA Entrada DE AIRE/AREAS DE Enfriamento SilenciadorLejos PuertoCubierta Para Desmontar LA Cortadora Servicio O DE Hacer AjustesCuidado Instalar LA S,EGADORA Y LA CorreaRegulacion Visual DE Lado a Lado Para Nivelar LA SegadoraREGULACI6N DE LA PRECISI6N DE Lado Ajuste DE Delante a AtrasSI6N DE Movimiento Para Cambiar LA Correa DE IMPUL=Desmontaje DE LA Correa Montaje DE LA Correa DE LA SEGA- DoraPara Verificar SI Funciona Bien EL Freno Impresion / Inclinacion DE LAS RUE=Reemplazar LA Bateria Para Adjuntar LOS Cables DE EmpalmePara Cambiar LA Bombilla DE LA LUZ Delantera Entreoierre Y RelesCarburador MotorOtros Aceite DEL MotorCilindros Problema Causa Correccion Identificacion DE ProblemasEstrangulacion Choke EL MotorCorreccjon IDENTIFICACI6N DE ProblemasProblemacausa Rapido Iproblema Causa CorreccionGUJASUGERiDAPARAMEDIR LAS Pendientes CON LA Vista Para UNA Our Home Your Home

YT 4500, 917.28990 specifications

The Craftsman 917.28990 YT 4500 is a robust lawn tractor that combines power and performance with comfort and ease of use, making it an ideal choice for homeowners with medium to large yards. With its impressive features and innovative technologies, this machine stands out in the competitive landscape of lawn care equipment.

At the heart of the Craftsman YT 4500 is a powerful 24 HP Kohler engine. This engine delivers reliable performance, ensuring that the tractor can tackle a variety of tasks from mowing to hauling and even towing. With a 42-inch cutting deck, the YT 4500 effectively maneuvers through tight corners and delivers a clean, professional-looking cut on your lawn.

One of the standout features of the Craftsman YT 4500 is its hydrostatic transmission, which provides effortless control and smooth operation. This technology allows users to change speed and direction easily without the need for constant gear shifting, enhancing the user experience, especially over extended periods of use.

The tractor also boasts a comfortable high-back seat with adjustable features, providing ample support during long mowing sessions. The ergonomically designed steering wheel allows for easy maneuverability, making it suitable for users of all sizes.

To improve efficiency, the YT 4500 is equipped with a cutting height adjustment feature, allowing users to select from multiple cutting heights to accommodate various grass types and conditions. This flexibility ensures optimal results year-round.

Additionally, the Craftsman 917.28990 includes a mulching feature, which finely chops grass clippings and returns them to the lawn as natural fertilizer, promoting a healthier lawn while reducing the need for bagging clippings. For those requiring extra versatility, the tractor is compatible with various attachments, including snow plows, baggers, and more, enabling year-round tasks.

Overall, the Craftsman 917.28990 YT 4500 is an excellent investment for any homeowner seeking reliability, comfort, and versatility in a lawn tractor. Its combination of power, advanced technologies, and thoughtful design ensures that lawn care can be both efficient and enjoyable. Whether you are tackling a simple mow or an extensive landscaping project, the YT 4500 proves to be a valuable addition to your outdoor equipment lineup.
Top Page Image Contents