Sears 917.258552 owner manual Cleaning, Muffler, Spark Plugs

Page 19

'

u,u

, r,

'lql

,

CUSTO

CLEAN AIR SCREEN (See Fig. 16)

Air screen must be kept free of dirt and chaff to prevent engine damage from overheating. Clean with a wire brush

or compressed air to remove dirt and stubborn dried gum fibers:

CLEAN AiR INTAKE/COOLING AREAS

To insure proper cooling, make sure the grass screen, cooiing fins, and other externa! surfaces of the engine are kept €lean at all times.

Every 100 hours of operation (more often under extremely dusty, dirty conditions), remove the blower housing and other cooling shrouds. Clean the cooling fins and external surfaces as necessary. Make sure the cooling shrouds are reinstalled.

NOTE: Operating the engine with a blocked grass screen, dirty or plugged cooling fins, and/or cooting shrouds re- moved will cause engine damage due to overheating.

ENGINE OIL FILTER (See Fig. 17)

Replace the engine oil fi_ter every season or every other oil change if the tractor is used more than 100 hours in one year.

=Drain oil from engine crankcase (See "TO CHANGE ENGINE OIL" in this section of this manual, through step remove drain plug),

•Remove oil filter and wipe off filter adapter.

Apply a thin coating of new engine oil to the rubber gasket on replacement oil filter,

-InstalJ replacement oil filter on filter adapter, Turn oit filter clockwise until rubber gasket contacts the filter adapter, then tighten filter an additional 1/2 turn.

-Fill crankcase with new oil (See "TO CHANGE EN- GINE OIL" in this section of this manual), For approxi- mate capacity see "PRODUCT SPECIFICATIONS" on page 3 of this manual.

•Start the engine and check for oil feaks. Correct any leaks before placing engine into full operation,

OiL FLTER

FiG. 17

,nun•

MUFFLER

inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and!or damage.

SPARK PLUGS

Replace spark plugs at the beginning of each mowing season or after every 100 hours of operation, whichever

occurs first. Spark ptug type and gap setting are shown in "PRODUCT SPECIFICATIONS" on page 3 of this manual.

IN-LINE FUEL FILTER (See Fig. 18)

The fuel filter should be replaced once each season. If fuel

fiIter becomes clogged, obstructing fue f owto carburetor, replacement is required.

®With engine coot, remove filter and plug fuel line sections.

-Place new fue! filter in position in fue! line with arrow pointing towards carburetor.

-Be sure there are no fuet line leaks and clamps are properly positioned.

*Immediately wipe up any spilled gasoline.

CLAMP

CLAMP

FUEL

FILTER

FIG. 18

CLEANING

Clean engine, battery, seat, finish, etc. of all foreign matter.

•Keep finished surfaces and wheels free of all gasoline, oil, etc.

•Protect painted surfaces with automotive type wax.

We do not recommend using a garden hose to clean your tractor unless the electrical system, muffler, air filter and

carburetor are covered to keep water out. Water in engine can result in a shortened engine life.

19

Page 18 Page 20
Image 19
Page 18 Page 20
Contents AFTZ II. Slope Operation Safety RulesModel Maintenance AgreementLimited TWO Year Warranty on Craftsman Riding Equipment Limited 90 DAY Warranty on BatteryIndex Performance EngineContents of Hardware Pack To Remove Tractor from Carton Tools Required for AssemblyHOW to SET UP Your Tractor ASS LYAssemble Gauge Wheels to Mower Deck See Fig AssemblyInstall Seat See Fig Check Deck LevelnessTo Convert to Bagging or Checklis TDschargng Slow Battery Reverse ForwardLock Know Your Tractor OperationTo SET Parking Brake See Fig HOW to USE Your TractorStopping See Fig To Operate on Hills Before Startwng the EngineADD Gasoline Purge Transmission 7ro Start Engine See FigHydrostatic Transmission Warm UP Mulching Mowng Tips ERAT!ONLUBRJCATmON Maintenance ScheduleChart General RecommendationsTires BatteryTractor Brake OperationTransaxle Pump Fluid EngineTR Filter See Fig. t6 Muffler CleaningSpark Plugs To Remove Mower See Fig To iNSTALL Mower See Fig, !9OFF To Level Mower Housing See Fig To Adjust Brake See FigTo Replace Mower Blade Drive Belt To Replace Motion Drive BeltFront Wheel TOE-INtCAMBER Service AN Adjustm NTSTo Adjust Motion Control Lever To Adjust Steering Wheel AlignmentTo Replace Headlight Bulb Service a AdjustmentsTo Start Engjne WiTH a Weak Battery See Fig To Remove Hood and Grill AssemblyTo Adjust Carburetor See Fig To Adjust Throttle Control CableEngine Engine OIL StorageOther FuelsystemCorrection TroubleshootingProblemcause PointsClutch CorrectbonTractor = Model Number Electrical Tractor - Model NumberKEY Tractor Model NumberPart Description Chassis and Enclosures NO. no KEY PartRepair pARTSTRACTORtooELNUMBER97..258552 DESCRePTON DriveSTL Tractor -- Model Number Steering AssemblyKEY Part NO. no TRACTOR-- Model NumberKEY Part Description Seat AssemblyTractor Model Number 917,258552 DescriptionWheels & Tires TRACTOR--MODELKEY Part NO. no Engine Optional Equipment NO. NO.DESCRiPTiON Engine426 161718 Tractor - Model Number 917,258552Mower Lift 150 \Locknut, Hex Tractor =- Model NumberKEY Part NO. NO. DESCRIPTtON105 Mower Deck106 DESCRmPTION Mower DeckKEY PartHydro Gear Transaxle Model Number Tractor == Model Number 917,258552142951 Hydro Gear Transaxle Model Number 310=0650NO. no Description RetainingTractor Model Number Not Illustrated KEY Part Tractor - Model Number 917Kohler Engine -- Model Number CV15S, Type Number PS-41526 Crankshaft KEY PartFuel System Tractor --MODEL Number 917,2585522227 Descripon Kohler Engine -MODEL Number CV15S, Type Number PB-41526Fuel System KEY Part NO. no Cylinder HEAD, Valve and BreatherKohler Engine Model Number CV15S Type Number PS-41526 Tractor = Model Number 917,258552Startn Starting System KEY Part NO. no Kohler Engine -- Model Number CV!5S, Type Number PS-41526Electrical Crankcase KEY PartService Notes Suggested Guide for Sighting Slopes for Safe Operation Orconsumer Assistance HOT LINE, Call this Toll Free Number Repair Service Or PartsFor Repair SERVICE, Call this Toll Free Number If YOU Need

917.258552 specifications

The Sears 917.258552 is a standout model in the lineup of lawn tractors offered by Sears. This versatile machine combines robust features and innovative technologies to provide homeowners with an efficient and effective solution for lawn maintenance.

One of the main features of the Sears 917.258552 is its powerful engine. Powered by a reliable 18.5 horsepower Briggs & Stratton engine, this lawn tractor is capable of tackling various lawn sizes and types. The engine's performance is enhanced by a smooth automatic transmission, which allows for easy speed adjustments on the go, ensuring that users can navigate their yards with ease and precision.

The cutting deck of the Sears 917.258552 measures a generous 42 inches, making it suitable for larger areas without sacrificing maneuverability. The deck design incorporates a durable steel construction, providing longevity and resilience against the rigors of regular lawn care. Additionally, it features a deck wash system, allowing users to clean the underside of the deck efficiently and maintain optimal cutting performance over time.

Another noteworthy technology included in this model is the cutting height adjustment feature. The Sears 917.258552 provides multiple cutting height settings, which can be easily adjusted to achieve the desired grass height. This flexibility allows users to manage their lawns' aesthetics while promoting healthy grass growth.

The tractor's ergonomics are designed with user comfort in mind. The high-back seat provides ample support during extended periods of operation, while the easy-to-reach controls facilitate a hassle-free mowing experience. With a tight turning radius, the Sears 917.258552 can navigate around obstacles effectively, making it an ideal choice for complex landscapes.

Moreover, this tractor is designed for storage and maintenance convenience. It features a compact design that simplifies storage, while the intuitive layout allows for easy maintenance access to key components, such as the battery and fuel system.

In summary, the Sears 917.258552 lawn tractor is an exceptional choice for homeowners looking for a reliable and efficient lawn care solution. With its powerful engine, durable cutting deck, adjustable cutting heights, ergonomic design, and ease of maintenance, this model epitomizes the blend of performance and user-friendly features that Sears aims to deliver in their lawn maintenance products. Whether for residential lawns or larger garden plots, the Sears 917.258552 is equipped to handle the task with efficiency and ease.
Top Page Image Contents