Sears 917.258552 owner manual Ass Ly, Tools Required for Assembly, To Remove Tractor from Carton

Page 7

ASS LY

111111 ii............

Your new tractor has been assembled at the factory with exception of those pa_s teft unassembled for shipping purposes. To ensure safe and proper operation of your tractor a{t parts and hardware you assemble must be tightened secureiy Use the correct tools as necessary to insure proper tightness.

TOOLS REQUIRED FOR ASSEMBLY

A socket wrench set will make assembly easier, Standard wrench sizes are listed.

(1)

9/16" wrench

Utility knife

(2)

7/!6 'wrenches

Phi!lips Screwdriver

(2)

1/2" wrenches

"Tire pressure gauge

(1)

3/4" Socket w/drive

rachet

When right or Ieft hand is mentioned in this manual, it means when you are in the operating position (seated behind the steering wheel).

TO REMOVE TRACTOR FROM CARTON

UNPACK CARTON

o Remove aN accessible loose parts and pads cartons from carton (See page 6).

,Cut, from top to bottom, along lines on all four corners of carton, and Iay panets flat.

•Check for any additional loose parts or cartons and remove.

STEERNG

STEERING

BOOT"

WHEEL

BEFORE ROLLNG TRACTOR OFF SKID

ATTACH STEERING WHEEL (See Fig. 1)

ASSEMBLE EXTENS!ON SHAFT AND BOOT

,Slide extension shaft onto lower steering shaft. Align mounting holes in extension and lower shafts and

ADAPTER

EXTENSION SHAFT

5116 HEX

install 5/16 hex bolt and 10cknuL Tighten securely.

IMPORTANT; TIGHTEN BOLT AND NUT SECURELY TO 18-22 FT. LBS TORQUE.

•Place tabs of steering boot over tab slots in dash and push down to secure.

iNSTALL STEERING WHEEL

=Position front wheels of the tractor so they are pointing straight forward.

•Slide steering wheel adapter onto steering shaft exten- sion.

-Position steering wheel so cross bars are horizontal 0eft to right) and slide onto adapter.

•Assemble large flat washer, 3/8 lock washer, 3/8 hex bolt and tighten securely,

•Snap steering wheel insert into center of steering wheel.

,Remove protective materials from tractor hood and grill.

IMPORTANT: CHECK FOR AND REMOVE ANY STAPLES IN SKID THAT MAY PUNCTURE TIRES

WHERE TRACTOR IS TO ROLL OFF SKID.

TO ROLL TRACTOR OFF SKID {See Opera- tion section for location and function of con-

trois)

. Press lift lever plunger and raise attachment lift lever to its highest position.

,Release parking brake by depressing dutch/brake pedal.

,Place freewheel control in freewheeling position to disengage transmission (See 'TO TRANSPORT" in the Operation section of this manual).

. Roll tractor backwards off skid.

,Remove banding holding discharge guard up against tractor,

5/16/

LOCKNUT/

f

!

•t

t

% /

FIG. 1

HOW TO SET UP YOUR TRACTOR

CONNECT BATTERY (See Figs. 2 and 3)

,,

, ii,,i,ilUlUll

,

u l

iii

i

CAUTION: Do not short battery termi- nals by allowing a wrench or any other object to contact both terminals at the same time. Before connecting battery, remove metal bracelets, wristwatch bands, rings, etc.

Positive termina! must be connected first to prevent sparking from accidental

grounding•

Remove carboard packing from seat pan and lift seat pan to raised position.

Open battery box door.

Be sure battery drain tube. is attached to battery box. Remove terminal protective caps and discard.

•If this battery is put into service after month and year indicated on label (label located between terminals) charge battery for minimum of one hour at 6-10 amps,

Page 6 Page 8
Image 7
Page 6 Page 8
Contents AFTZ II. Slope Operation Safety RulesModel Maintenance AgreementLimited TWO Year Warranty on Craftsman Riding Equipment Limited 90 DAY Warranty on BatteryIndex Performance EngineContents of Hardware Pack To Remove Tractor from Carton Tools Required for AssemblyHOW to SET UP Your Tractor ASS LYAssemble Gauge Wheels to Mower Deck See Fig AssemblyInstall Seat See Fig Check Deck LevelnessTo Convert to Bagging or Checklis TDschargng Slow Battery Reverse ForwardLock Know Your Tractor OperationTo SET Parking Brake See Fig HOW to USE Your TractorStopping See Fig To Operate on Hills Before Startwng the EngineADD Gasoline Purge Transmission 7ro Start Engine See FigHydrostatic Transmission Warm UP Mulching Mowng Tips ERAT!ONLUBRJCATmON Maintenance ScheduleChart General RecommendationsTires BatteryTractor Brake OperationTransaxle Pump Fluid EngineTR Filter See Fig. t6 Muffler CleaningSpark Plugs To Remove Mower See Fig To iNSTALL Mower See Fig, !9OFF To Level Mower Housing See Fig To Adjust Brake See FigTo Replace Mower Blade Drive Belt To Replace Motion Drive BeltFront Wheel TOE-INtCAMBER Service AN Adjustm NTSTo Adjust Motion Control Lever To Adjust Steering Wheel AlignmentTo Replace Headlight Bulb Service a AdjustmentsTo Start Engjne WiTH a Weak Battery See Fig To Remove Hood and Grill AssemblyTo Adjust Carburetor See Fig To Adjust Throttle Control CableEngine Engine OIL StorageOther FuelsystemCorrection TroubleshootingProblemcause PointsClutch CorrectbonTractor = Model Number Electrical Tractor - Model NumberKEY Tractor Model NumberPart Description Chassis and Enclosures NO. no KEY PartRepair pARTSTRACTORtooELNUMBER97..258552 DESCRePTON DriveSTL Tractor -- Model Number Steering AssemblyKEY Part NO. no TRACTOR-- Model NumberKEY Part Description Seat AssemblyTractor Model Number 917,258552 DescriptionWheels & Tires TRACTOR--MODELKEY Part NO. no Engine Optional Equipment NO. NO.DESCRiPTiON Engine426 161718 Tractor - Model Number 917,258552Mower Lift 150 \Locknut, Hex Tractor =- Model NumberKEY Part NO. NO. DESCRIPTtON105 Mower Deck106 DESCRmPTION Mower DeckKEY PartHydro Gear Transaxle Model Number Tractor == Model Number 917,258552142951 Hydro Gear Transaxle Model Number 310=0650NO. no Description RetainingTractor Model Number Not Illustrated KEY Part Tractor - Model Number 917Kohler Engine -- Model Number CV15S, Type Number PS-41526 Crankshaft KEY PartFuel System Tractor --MODEL Number 917,2585522227 Descripon Kohler Engine -MODEL Number CV15S, Type Number PB-41526Fuel System KEY Part NO. no Cylinder HEAD, Valve and BreatherKohler Engine Model Number CV15S Type Number PS-41526 Tractor = Model Number 917,258552Startn Starting System KEY Part NO. no Kohler Engine -- Model Number CV!5S, Type Number PS-41526Electrical Crankcase KEY PartService Notes Suggested Guide for Sighting Slopes for Safe Operation Orconsumer Assistance HOT LINE, Call this Toll Free Number Repair Service Or PartsFor Repair SERVICE, Call this Toll Free Number If YOU Need

917.258552 specifications

The Sears 917.258552 is a standout model in the lineup of lawn tractors offered by Sears. This versatile machine combines robust features and innovative technologies to provide homeowners with an efficient and effective solution for lawn maintenance.

One of the main features of the Sears 917.258552 is its powerful engine. Powered by a reliable 18.5 horsepower Briggs & Stratton engine, this lawn tractor is capable of tackling various lawn sizes and types. The engine's performance is enhanced by a smooth automatic transmission, which allows for easy speed adjustments on the go, ensuring that users can navigate their yards with ease and precision.

The cutting deck of the Sears 917.258552 measures a generous 42 inches, making it suitable for larger areas without sacrificing maneuverability. The deck design incorporates a durable steel construction, providing longevity and resilience against the rigors of regular lawn care. Additionally, it features a deck wash system, allowing users to clean the underside of the deck efficiently and maintain optimal cutting performance over time.

Another noteworthy technology included in this model is the cutting height adjustment feature. The Sears 917.258552 provides multiple cutting height settings, which can be easily adjusted to achieve the desired grass height. This flexibility allows users to manage their lawns' aesthetics while promoting healthy grass growth.

The tractor's ergonomics are designed with user comfort in mind. The high-back seat provides ample support during extended periods of operation, while the easy-to-reach controls facilitate a hassle-free mowing experience. With a tight turning radius, the Sears 917.258552 can navigate around obstacles effectively, making it an ideal choice for complex landscapes.

Moreover, this tractor is designed for storage and maintenance convenience. It features a compact design that simplifies storage, while the intuitive layout allows for easy maintenance access to key components, such as the battery and fuel system.

In summary, the Sears 917.258552 lawn tractor is an exceptional choice for homeowners looking for a reliable and efficient lawn care solution. With its powerful engine, durable cutting deck, adjustable cutting heights, ergonomic design, and ease of maintenance, this model epitomizes the blend of performance and user-friendly features that Sears aims to deliver in their lawn maintenance products. Whether for residential lawns or larger garden plots, the Sears 917.258552 is equipped to handle the task with efficiency and ease.
Top Page Image Contents