White Outdoor 500 manual Electric Starter, Cold Start, Warm Start, Frozen Recoil Starter

Page 10

(inside the boot) is fastened securely over the metal tip on the spark plug.

•Make certain both the auger control and drive control are in the disengaged (released) position.

•Move throttle control up to FAST position. Insert

ignition key into slot. Make sure it snaps into place. Do not attempt to turn the key.

NOTE: The engine cannot start unless the key is inserted into ignition switch.

Electric Starter

Before starting, make sure that the engine has suffi- cient oil. The snow thrower engine is equipped with a 120 volt A.C. electric starter and recoil starter. The electric starter is equipped with a three-wire power cord and plug and is designed to operate on 120 volt AC household current. Follow all instructions carefully.

Cold Start

NOTE: If the unit shows any sign of motion (drive or augers) with the clutch grips disengaged, shut the engine off immediately. Readjust as instructed in the “Final Adjustments” section of the Assembly Instructions.

WARNING: The electric starter must be properly grounded at all times to avoid the possibility of electric shock which may be injurious to the operator.

1.Determine whether your house wiring is a three- wire grounded system. Ask a licensed electrician if you are not certain.

WARNING: If your house wiring system is not a three-wire grounded system, do not use this electric starter under any conditions.

•If your house wiring system is grounded and a three-hole receptacle is not available at the point the snow thrower starter will normally be used, one should be installed by a licensed electrician.

•When connecting the power cord, always connect cord to starter on engine first, then plug the other end into a three-hole grounded receptacle.

•When disconnecting the power cord, always

unplug the end from the three-hole, grounded receptacle first.

2.Attach spark plug wire to spark plug.

3.Make sure that the auger drive and the traction drive levers are in the disengaged position.

4.Move throttle control lever to FAST position.

5.Push key into the ignition slot. Make sure it snaps into place. Do not turn key.

6.Rotate the choke knob to FULL choke position.

7.Push the primer three times.

8.Connect power cord to switch box on the engine.

9.Plug the other end of the power cord into a three-

hole, grounded 120 volt A.C. receptacle.

10.Push down on the starter button until the engine starts. Do not crank for more than 10 seconds at a time. This electric starter is thermally protected. If overheated, it will stop automatically and can be restarted only when it has cooled to a safe temperature (a wait of 5 -10 minutes is required).

11.When the engine starts, release the starter button and slowly rotate the choke to OFF position. If the engine falters, rotate the choke to FULL and then gradually to OFF.

12.Disconnect the power cord from the receptacle first and then from the switch box on the engine.

13.Allow the engine to warm up for a few minutes because the engine will not develop full power until it reaches operating temperature. Operate the engine at full throttle (FAST) when throwing snow.

Warm Start

1.If restarting a warm engine, rotate choke to OFF instead of FULL and press the starter button.

Recoil Starter

Make sure that the engine has sufficient oil and the auger drive and the traction drive levers are released.

Cold Start

1.Move throttle control to FAST position.

2.Push key into the ignition slot so that it snaps into place. Do not turn key.

3.Rotate choke control to FULL choke position.

4.Push the primer button while covering the vent hole. Remove your finger from the primer between primes. Do not prime if temperature is above 50o F (10o C); prime two times between 50o F (10o C) and 15o F (-9oC); and prime four times below 15o F (-9oC).

5.Pull the starter handle rapidly. Do not allow the handle to snap back, but allow it to rewind slowly while keeping a firm hold on the starter handle.

6.As the engine warms up and begins to operate evenly, rotate the choke knob slowly to OFF position. If the engine falters, return to FULL choke, then slowly move to OFF choke position.

7.Allow the engine to warm up for a few minutes because the engine will not develop full power until it reaches operating temperature.

8.Operate the engine at full throttle (FAST) when throwing snow.

Warm Start

1.If restarting a warm engine after a temporary shut down, rotate choke to OFF instead of FULL and do not prime. Pull starter handle as instructed earlier.

Frozen Recoil Starter

If the starter is frozen and will not turn the engine, proceed as follows:

1.Pull as much rope out of the starter as possible.

2.Release the starter handle and let it snap back

10

Page 9 Page 11
Image 10
Page 9 Page 11
Contents Operator’s Manual Table of Contents Important Safe Operation Practices TrainingMaintenance And Storage Your ResponsibilitySetting up the Snow Thrower Setting UP Your Snow ThrowerBefore Assembly UnpackingChute Clean-Out Tool Final AdjustmentsLamp Wire optional For Models with 4 Way Chute Control BoxDrive Control & Shift Lever Auger Control TestSkid Shoe Tire Pressure Pneumatic Tires Operating Your Snow ThrowerKnow The Controls Drive Control/ Auger Control LockBefore Starting Gas & Oil Fill-Up Stopping Snow ThrowerStarting The Engine Cold Start Electric StarterRecoil Starter Warm StartTo Engage Drive Before StoppingTo Stop The Snow Thrower To Engage AugersGeneral Recommendations Chute Clean-Out ToolMaintaining Your Snow Thrower EngineCheck Friction Wheel Service & AdjustmentCheck V-Belts Check Chute CablesReplacing Skid Shoe Replacing BeltShave Plate and Skid Shoes Auger BeltFriction Wheel Rubber Drive BeltAuger Clutch AdjustmentsDrive Clutch Shift RodOFF-SEASON Storage Chute ControlTroubleshooting Three 3 Year Limited Warranty Tractor Attachment Warranty
Related manuals
Manual 16 pages 26.46 Kb

500 specifications

The White Outdoor 500 is a rugged and versatile lawn and garden tractor designed for homeowners looking to tackle a variety of outdoor tasks with ease. Renowned for its robust construction and reliable performance, the White Outdoor 500 is equipped with a host of features that make it a valuable addition to any landscape maintenance arsenal.

One of the standout features of the White Outdoor 500 is its powerful engine, typically powered by a dependable Briggs & Stratton or Kohler engine. This engine provides ample horsepower to handle a wide range of conditions, from mowing grassy lawns to tackling tougher terrain and heavy gardening tasks. The engine is designed for easy starting and efficient fuel consumption, ensuring that homeowners can complete their tasks without frequent interruptions for refueling.

The tractor is equipped with a hydrostatic transmission, offering seamless acceleration and smooth operation. This user-friendly system allows operators to easily control speed and direction without the need for shifting gears, enabling a more comfortable mowing experience. The tractor's design promotes maneuverability, making it suitable for navigating around obstacles like trees and flower beds.

Another key characteristic of the White Outdoor 500 is its cutting deck. The tractor typically features a wide, multi-blade cutting system that ensures a clean and even cut across various grass types and lengths. Many models include adjustable cutting heights, allowing users to customize their lawn care according to seasonal requirements or personal preferences. The robust construction of the deck ensures durability, even under the rigors of regular use.

The White Outdoor 500 also prioritizes comfort and ease of use. With an ergonomic seat design, users can enjoy extended mowing sessions without experiencing fatigue. The placement of controls is intuitive, making it easy to operate various functions like headlights, deck engagement, and throttle adjustments.

In addition, the tractor often features advanced technologies such as a built-in mulching system and bagging capabilities that allow homeowners to collect clippings for easy disposal or recycling. As a result, maintaining a tidy lawn becomes a simple affair.

Overall, the White Outdoor 500 is a reliable and efficient lawn tractor that combines power, comfort, and advanced features for a superior mowing experience, making it a popular choice among homeowners looking for a dependable solution to their outdoor maintenance needs.
Top Page Image Contents