North Star M165938N owner manual Reference 9 Vibration

Page 10

Machine Component Identification - Item #165938N

Reference 9 – Vibration

The engine and generator are mounted on rubber

Isolation Mounts

cylinders that absorb most of the engine vibration.

 

This feature eliminates the tendency of the machine to

 

“walk” which is common in engine powered equipment.

Reference 10 – Oil Drain Plug

Refer to your Honda engine manual for oil change

 

recommendations.

Reference 11 – Super Silent

Noise level is 8 dB less than Honda’s standard muffler.

Muffler

 

Reference 12 – Air Cleaner

Refer to your Honda engine manual for air cleaner

 

care.

Reference 13 – Engine Key

The engine key is located on the engine. Always

Switch

locate this switch and be familiar with its location

 

before operating the generator. Consult the Honda

 

engine owner’s manual for further instructions.

Reference 14 – Fuel Valve

The engine has an ON-OFF valve mounted on the

 

front of the engine. Always keep this valve closed

 

when the generator is not in use.

Reference 15 – Choke Lever

Used during cold starts. The choke is only used with

 

gasoline fuel. Refer to Honda engine manual for

 

usage.

Reference 16 – Recoil

Grasp firmly when starting engine.

Reference 17 – LPG / NG – ¾”

Before you start engine, smell next to floor for gas, if

NPT Inlet

you do smell gas:

 

• DO NOT start engine.

 

• DO NOT light a match.

 

• DO NOT flip on an electrical switch.

 

• Exit area immediately and call gas supplier or

 

fire department.

 

Minimum flow range required: NG - 2.0 CFM,

 

LPG - 5.7 lb/hr.

 

Pressure Range: 4-6 ounces, OR 7-11 inches of water

 

column. NEVER over pressurize.

Reference 18 – Demand

Supplies the engine LP or NG fuel only if the engine is

Regulator

running.

Reference 19 – Generator Head

The electricity producing part of the generator.

10

Page 9 Page 11
Image 10
Page 9 Page 11
Contents Any Questions, Comments, Problems, or Parts Orders Watt Continuous 8,000 Watt Surge CapacityHazard Signal Word Definitions Table of Contents About Your Generator About Your GeneratorAbout Your Generator cont’d Read this ManualSpecifications Specifications Item #165938NSafety Label Locations Item #165938N Part numbers DescriptionMachine Component Identification Item #165938N DescriptionReference Guide Reference 9 Vibration Power Load Planning & Management Example conversion to wattsPower Load Planning & Management cont’d ExamplePlanning the Power Load Installation / Initial Set-UpUnpacking & Delivery Inspection Propane LPG Gas Hook-up Installation for Natural Gas or LPG if neededHook-up Generator Installation / Initial Set-Up Set-up either as a Building BACK-UP or Portable Power Source Nema Current/Power Maximum Extension Cord Length Monoxide exhaust Select a Suitable SiteOutdoors only Away from all air intakesStructure allow at least a 7’ clearance Grounding the generator Battery Installation General safety rules for operation OperationOperation cont’d Operation cont’d Check the oil level using the dipstick and add oil as needed Preparing for OperationGenerator on gasoline Start LPG/NG supply If using Natural GasOperation cont’d Using LP/NG To start engine using LP or Natural Gas Starting the EngineTo start engine using gasoline Checking Generator Output Connecting Loads Stop the engine using the following steps Switching Fuels during operationStopping When you are finished using the generator, you must Storage & ExerciseOperation cont’d Maintenance & Repair Maintenance & RepairMaintenance & Repair cont’d Troubleshooting TroubleshootingBattery Safety Summary of Important Safety Information for OperationSafety Installation & Set-up GeneralInstallation / Initial Set-up Safety Safety Before UseKnow how to operate Propane & Natural Gas Safety Safety During UseGasoline Safety Personal protective equipmentSummary of Important Safety Information for Operation cont’d Safety After use Safety Inspection/MaintenanceGenerator Exploded View Rev- N Diag # Description Qty Wiring Diagram Rev- N Generator Head Exploded View Rev- N Item # Description Qty
Top Page Image Contents