North Star M165938N owner manual Diag # Description Qty

Page 46

Generator Exploded View Rev- N


	Diag #	Part #	Description	Qty

	1	171410	Hose Clamp	5
	2	777164	Positive Battery Cable	1
	3	38759	Fuel Tank Assembly	1
	4	30754	Leather Washer	4
	5	779422	Decal	1
	6	32833	Roll Cage	1
	7	33482	6mm Stud and Coupler Nut	1
	8	36298	Straight Hose Nipple	1
	9	36297	Load Block	1
	10	31770	Engine Adapter	1
	11	32811	LP/NG Hose	22”
	12	31335	Engine, GX390 Honda	1
	13	778530	Generator	1
	14	777304	Generator Cover	1
	15	36300	Regulator Assembly	1
	16	33319	LP/NG Fuel Lockoff	1
	17	777338	3/8 X 1/4 Reducer	1
	18	777119	1/2” Hose Clamp	2
	19	32798	3/4” Pipe	1
	20	35946	O-Ring	1
	21	36825	Regulator	1
	22	33435	Regulator Bracket	1
	23	31708	3/8” Split Conduit	7”
	24	31772	Vacuum Switch	1
	25	32815	Wire Harness	1
	26	32809	Elbow	1
	27	32810	Vacuum Hose	22”
	28	306459	Ground Wire	1
	29	777621	Generator Base Bracket	1
	30	33321	Fuel Cap	1
	31	34172	Isolation Mount	4
	32	32844	Lower Bracket	4
	33	778483	Generator Base	1
	34	82018	5/16-18 X 2 Hex Head Bolt	4
	35	777305	Control Box	1
	36	33277	Clip Nut, 10-32	4
	37	32797	10-32 X .75 Screw	4
	38	777108	Negative Battery Cable	1
	39	38435	Control Panel Assembly	1
	40	779396	Battery Decal	1
	41	777352	Battery Box	1
	42	31868	Battery (Not Included)	1
	43	32848	Upper Bracket	4
	44	31850	Wire Harness	1
	45	779424	Warning Decal	1
	46	33484	Nameplate	1
	47	30755	Fuel Filter	1
	48	777345	1/4” Fuel Line	15”
	49	38184	Engine Cover	1
	50	39260	Burn Warning	1
	51	32813	1/4” NPT, 1/4” Hose Barb	2
	52	777163	Gas Lockoff Bracket	1
	53	777147	Gasoline Lockoff	1

46

Image 46

Contents Any Questions, Comments, Problems, or Parts Orders Watt Continuous 8,000 Watt Surge CapacityHazard Signal Word Definitions Table of Contents About Your Generator About Your GeneratorAbout Your Generator cont’d Read this ManualSpecifications Specifications Item #165938NSafety Label Locations Item #165938N Part numbers DescriptionMachine Component Identification Item #165938N DescriptionReference Guide Reference 9 Vibration Power Load Planning & Management Example conversion to wattsPower Load Planning & Management cont’d ExamplePlanning the Power Load Installation / Initial Set-UpUnpacking & Delivery Inspection Propane LPG Gas Hook-up Installation for Natural Gas or LPG if neededHook-up Generator Installation / Initial Set-Up Set-up either as a Building BACK-UP or Portable Power Source Nema Current/Power Maximum Extension Cord Length Monoxide exhaust Select a Suitable SiteOutdoors only Away from all air intakesStructure allow at least a 7’ clearance Grounding the generator Battery Installation General safety rules for operation OperationOperation cont’d Operation cont’d Check the oil level using the dipstick and add oil as needed Preparing for OperationGenerator on gasoline Start LPG/NG supply If using Natural GasOperation cont’d Using LP/NG To start engine using LP or Natural Gas Starting the EngineTo start engine using gasoline Checking Generator Output Connecting Loads Stop the engine using the following steps Switching Fuels during operationStopping When you are finished using the generator, you must Storage & ExerciseOperation cont’d Maintenance & Repair Maintenance & RepairMaintenance & Repair cont’d Troubleshooting TroubleshootingBattery Safety Summary of Important Safety Information for OperationSafety Installation & Set-up GeneralInstallation / Initial Set-up Safety Safety Before UseKnow how to operate Propane & Natural Gas Safety Safety During UseGasoline Safety Personal protective equipmentSummary of Important Safety Information for Operation cont’d Safety After use Safety Inspection/MaintenanceGenerator Exploded View Rev- N Diag # Description Qty Wiring Diagram Rev- N Generator Head Exploded View Rev- N Item # Description Qty