TROUBLESHOOTING 
| Problem | Possible Causes | Possible Remedies |
| ||
| Engine will not start. | a) | Low oil level. | a) | Fill crankcase to proper oil level. |
|
|
| b) | Fouled spark plug. | b) | Clean or replace spark plug. |
|
|
| c) | Out of fuel. | c) | Fill fuel tank. |
|
|
| d) | Stop switch in OFF position. | d) | Place switch in ON position. |
|
|
| e) | Battery has lost its charge. | e) | Battery has low electrolyte and/or |
|
|
|
|
| needs to be charged or replaced. |
| |
|
| f) | Engine fuse is blown. | f) | Replace fuse. 30A Buss type fuse, |
|
|
|
|
| located near starter motor. |
| |
| Voltage too low. | a) | Engine speed too slow. | a) | Bring generator to a qualified |
|
|
|
|
| technician for adjustment. |
| |
|
| b) | Generator is overloaded. | b) | Reduce the load. (See Load |
|
|
|
|
| Application section of this manual.) |
| |
|
| c) | Voltage regulator out of adjustment. | c) | Bring generator to a qualified |
|
|
|
|
| technician for adjustment. |
| |
| Circuit breaker trips. | a) | Defective load connected to generator. | a) | Disconnect load. |
|
|
| b) | Defective receptacle. | b) | Replace receptacle. |
|
|
| c) | Generator overloaded. | c) | Reduce the load. (See Load |
|
|
|
|
| Application section of this manual.) |
| |
| Voltage too high. | a) | Engine speed too high. | a) | Bring generator to a qualified |
|
|
|
|
| technician for adjustment. |
| |
|
| b) | Voltage regulator out of adjustment. | b) | Bring generator to a qualified |
|
|
|
|
| technician for adjustment. |
| |
| Generator overheating. | a) | Generator is overloaded. | a) | Reduce the load. (See Load |
|
|
|
|
| Application section of this manual.) |
| |
|
| b) | Insufficient ventilation. | b) | Make sure there is at least 3 feet of |
|
|
|
|
| clearance on all sides of generator. |
| |
| No output voltage. | a) | Defective load connected to generator. | a) | Disconnect load. |
|
|
| b) | Broken or loose wire. | b) | Bring generator to a qualified |
|
|
|
|
| technician for repair. |
| |
|
| c) | Defective receptacle. | c) | Replace receptacle. |
|
|
| d) | Defective stator. | d) | Bring generator to a qualified |
|
|
|
|
| technician for repair. |
| |
|
| e) | Defective rotor. | e) | Bring generator to a qualified |
|
|
|
|
| technician for repair. |
| |
|
| f) | Defective capacitor. | f) | Bring generator to a qualified |
|
|
|
|
| technician for repair. |
| |
|
| g) | Voltage regulator fuse has blown. | g) | Bring generator to a qualified |
|
|
|
|
| technician for repair. |
| |
| Engine lacks power. | a) | Generator is overloaded. | a) | Reduce the load. (See Load |
|
|
|
|
| Application section of this manual.) |
| |
|
| b) | Dirty air filter. | b) | Clean or replace air filter. |
|
| Engine shuts down | a) | Out of fuel. | a) | Fill fuel tank. |
|
| during operation. | b) | Low oil level. | b) | Fill crankcase to proper oil level. |
|
9