MTD MMZ 2560, MMZ 2554, MMZ 2254 Yearly Checks, Check the oil in the hydraulic reservoir

Page 28

1.Change the engine oil filter. (Every 50 hours under heavy duty operation.)

2.Check the engine spark plugs.

E.Yearly Checks

Check the oil in the hydraulic reservoir.

* Perform maintenance more frequently under dusty conditions.

Oil CHART

Apply a few drops of SAE 20W-50 engine oil or use a spray lubricant. Apply the oil to both sides of pivot points. Wipe off any excess. Start engine and operate mower briefly to insure that oil spreads evenly.

Number of Oil

 

Points

Description

 

 

Daily

 

4

Deck Suspension Pivots

4Height Adjustment Turnbuckle Clevis Pin

2Height Adjustment Handle Pivots

2

Height Adjustment Stop Pivots

2

Deck Lift Linkage Pivots

2

Transport Handle Pivots

1Transport Handle Pin

2Deck Frame Up-and-Down Pivots

WEEKLY

1Seat Hinge

2Steering Lever Linkage Rod End Bearings

2Lever Return Assembly Rod End Bearings

2

Pump Control Lever Pivots

1

Brake Lever Pivot Clevis Pin

1

Brake Lever Control Rod Pivot

1

Brake Control Rod Swivel Joint

4

Brake Rod Clevis Pins

2

Brake Shaft Assembly Pivots

2Grass Collection System Lid Hinges

(If Mower is so equipped)

28

Page 27 Page 29
Image 28
Page 27 Page 29
Contents Commercial Riding Mower Table of Contents Forward General Safety PrecautionsRelated to Fuel When Mowing Specifications Operating Instructions ControlsPage Seat Adjustment Lever The Seat Initial AdjustmentsCheck the fluid levels and tires Vice SJ Break-In And Operation Lubricate all fittings listed in the maintenance sectionStart the Engine Page Maintenance and Service Mower DeckParking the Mower Removing the Mower DeckChanging a Blade Changing the Blade Drive Belts Stop the engine and remove the key from the ignition switch Changing the Spindle AssemblyHydraulic Oil Electrical Circuit Draining Hydraulic OilInstalling the Battery Battery RemovalSpecific Freezing Gravity Temp F Jump Starting Page Tires Inflation PressureBrakes Hydraulic System Hydraulic Oil Tank and FilterRemoving the cap to prevent dirt from contaminating the oil Page To Put the Mower Back in Service StorageMaintenance Schedule Daily ChecksEvery 25 Hour Checks Weekly or Every 50 Hour ChecksYearly Checks Check the oil in the hydraulic reservoirLubrication Chart Wiring Diagram Page Equipment TWO-YEAR Limited Warranty
Top Page Image Contents