Multiquip MVH-120GH manual Belt Check, Belt Hazard

Page 15

Vibrator Oil Check

1.With handle bar positioned vertically (storage position), remove the breather cap (Figure 6) from the breather plug.

2.Use a 24 mm wrench and remove breather plug (Figure 6). Visually check to see if hydraulic oil comes up to the oil level line that is etched on the back side of the handle.

CAP

BREATHER

PLUG

OIL LEVEL

HAND PUMP

Figure 6.Vibrator Oil Gauge

2.If the hydraulic oil level is low, replace with "Shell Tellus" oil #46 or equivalent.

V-Belt Check

CAUTION

NEVERattempttochecktheV-beltwiththeenginerunning. Severeinjurycanoccurofyourhand(Figure7)getscaught betweentheV-beltandtheclutch.Alwaysusesafetygloves.

CLUTCH

PULLEY

VIBRATOR

PULLEY

Figure 7.V-Belt Hazard

MVH-120GH — INSPECTION

1.To check theV-belt tension (Figure 8 ), remove upper belt cover.

Figure 8.V-Belt Location

2.The V-belt tension is proper if the V-belt bends 10 to 15 mm (Figure 9) when depressed with finger at midway between the clutch and vibration pulley shafts.

Figure 9.V-BeltTension

3.A loose V-belt will decrease the power transmission output, causing reduced compaction and premature wear of the belt. V-belt in use is RPF-3320 (A-32 is also usable).

4.If the V-belt becomes worn or loose, replace it by using V- belt part number RPF-3320 or A-32.

MVH-120GH — OPERATION AND PARTS MANUAL — REV. #03 (10/24/07) — PAGE 15

Page 14 Page 16
Image 15
Page 14 Page 16
Contents Model MVH-120GH 2 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Proposition 65WARNINGMVH-120GH Operation and Parts Manual REV. #03 10/24/07 Table of Contents Parts Ordering Procedures Best Deal! Order via Internet Dealers OnlyOrder via Fax Dealers Only 6 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 SafetyAlways wear approved eye and hearing protection 8 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Rules for Safe OperationRules for Safe Operation 10 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH SpecificationsFrequency/Speed Definition of Plate CompactorVibratory Plates ReversibleVibratory Plates Forward 12 MVH-120GH Operation and Parts Manual REV. #3 10/24/07MVH-120GH Components Honda GX160 Engine 14 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH InspectionBelt Hazard Belt Check16 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH Initial START-UPStopping the Engine Starter GripMVH-120GH Operation Operation18 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Hours of Operation Inspection and Maintenance ServiceTablesDaily Service Machine Inspection20 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH MaintenanceTroubleshooting Hydraulic OilReplacing Hydraulic Oil 22 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH Preparation for Long -TERM StorageEngine Troubleshooting MVH-120GH -TROUBLESHOOTING Engine24 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Engine TroubleshootingPlate Compactor Troubleshooting MVH-120GH -TROUBLESHOOTING Plate CompactorRemarks Column NO. ColumnPart NO. Column QTY. ColumnQty Description Remarks MVH-120GH Suggested Spare PartsMVH-120GH Name Plate and Decals Name Plate and Decals28 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 DECAL, Caution MVH-120 30 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH -VIBRATING Plate AssyVibrating Plate Assy MVH-120GH Body ASSY. OLD Version Body ASSY. Serial Number L3029 and below32 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 WASHER, Lock M8 MVH-120GH Body ASSY. NEW Version Body ASSY. Body ASSY. Serial Number L3030 and Above34 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 BASE, Separate Handle Type MVH-120GH -VIBRATOR ASSY. OLD Version Vibrator ASSY. Serial Number L3112 and below36 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH Vibrator ASSY. OLD Version MVH-120GH -VIBRATOR ASSY. NEW Version Vibrator ASSY. Serial Number L3113 and Above38 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH Vibrator ASSY. NEW Version MVH-120GH Control ASSY. Oldversion Control ASSY. Serial NO. L3080 and below40 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH Control ASSY. OLD Version 42 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Control ASSY. Serial NO. L3081 and AboveNUT M16 MVH-120GH Control ASSY. NEW VersionHonda GX160 Engine Cylinder Head Assy Cylinder Head Assy44 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Cover COMP., Head Includes Item W/ %CLIP, Vlave Guide GASKET, Cylinder HeadHonda GX160 Engine Cylinder Barrel Assy Cylinder Barrel Assy46 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 PIN, Governor Weight Switch ASSY., OIL LevelWEIGHT, Governor HOLDER, Governor WeightHonda GX160 Engine Crankcase Cover Assy Crankcase Cover Assy48 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Gasket Crankcase PACKING, OIL Filler CAPOIL Seal Honda GX160 Engine Crankshaft Assy Crankshaft Assy50 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Crankshaft Comp BoltWasher 8 MM KEY 5X5X33 YellowHonda GX160 Engine Piston Assy Piston Assy52 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Piston STD BOLT, Connecting RODRing SET, Piston STD Ring SET, PistonHonda GX160 Engine Camshaft Assy Camshaft Assy54 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 ARM, Valve Rocker SPRING, Weight ReturnNUT, Pivot Adjusting ROD, PushHonda GX160 Engine Recoil Starter Assy Recoil Starter Assy56 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 GUIDE, Ratchet REEL, Recoil StarterRachet Starter PLATE, FrictionHonda GX160 Engine FAN Cover Assy FAN Cover Assy58 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Alert UNIT, OIL Cover COMP., FAN NH1Shroud Comp CLIP, HarnessHonda GX160 Engine Carburetor Assy Carburetor Assy60 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Screw SET, Pilot PLATE, Lever SettingFloat Valve SET Float SETHonda GX160 Engine AIR Cleaner Assy AIR Cleaner Assy62 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 PACKING, Elbow COVER, AIR CleanerGROMET, AIR Cleaner COLLAR, AIR CleanerHonda GX160 Engine Muffler Assy Muffler Assy64 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 ARRESTOR, Spark Muffler CompPROTECTOR, Muffler Deflector CompHonda GX160 Engine Fueltank Assy Fuel Tank Assy66 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Flange NUT 6 MM Includes Item W/+FILTER, Fuel Fuel Tank CompHonda GX160 Engine Flywheel Assy Flywheel Assy68 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 PULLEY, Starter Flywheel CompWoodruff KEY FAN, CoolingHonda GX160 Engine Ignition Coil Assy Ignition Coil Assy70 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 36101ZE1010 Honda GX160 Engine Control Assy Control Assy72 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 ARM, Governor Wire HolderSPRING, Governor BOLT, Governor ARMHonda GX160 Engine Label Assy Label Assy74 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MARK, Throttle Indication MARK, ChokeMARK, Choke Gray MARK, OIL Alert ExternalHonda GX160 Engine -TOOLS Assy Tools Assy76 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 HANDLE, BOX Wrench Part NameFreight Policy 78 MVH-120GH Operation and Parts Manual REV. #3 10/24/07MVH-120GH Operation and Parts Manual REV. #03 10/24/07 HERE’S HOW to GET Help
Top Page Image Contents