Multiquip manual MVH-120GH Components Honda GX160 Engine

Page 13

MVH-120GH — COMPONENTS (HONDA GX160 ENGINE)

Figure 2. Engine Controls & Components

1. Fuel Filler Cap – Remove this cap to add unleaded gasoline to the fuel tank.Make sure cap is tighten securely.

	DO NOT over fill.
2.	Throttle Lever – Used to adjust engine speed (fast-slow).
3.	Recoil Starter (pull rope) –Type of engine starting method.
	Alternate type would be electric start (ignition key).
4.	Starter Grip – Grip this handle to start engine. See engine
	starting section of this manual.
5.	Fuel Valve Lever – OPEN to let fuel flow, CLOSE to stop
	the flow of fuel.

7.	Air Cleaner – Prevents dirt and other debris from entering
	the fuel system. Remove wing-nut on top of air filter
	cannister to gain access to filter element.
8.	Spark Plug – Provides spark to the ignition system. Set
	spark plug gap to 0.6 - 0.7 mm (0.028 - 0.031 inch). Clean
	spark plug once a week.
9.	Muffler – Used to reduce noise and emissions.
10.	Fuel Tank – Holds 3.6 liters (approximately 1 gallon) of
	unleaded gasoline.

6. Choke Lever – Used in the starting of a cold engine, or in cold weather conditions. The choke enriches the fuel mixture.

MVH-120GH — OPERATION AND PARTS MANUAL — REV. #03 (10/24/07) — PAGE 13

Image 13

Contents Model MVH-120GH 2 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Proposition 65WARNINGMVH-120GH Operation and Parts Manual REV. #03 10/24/07 Table of Contents Best Deal! Order via Internet Dealers Only Parts Ordering ProceduresOrder via Fax Dealers Only 6 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 SafetyAlways wear approved eye and hearing protection 8 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Rules for Safe OperationRules for Safe Operation 10 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH SpecificationsVibratory Plates Definition of Plate CompactorReversibleVibratory Plates Frequency/SpeedForward 12 MVH-120GH Operation and Parts Manual REV. #3 10/24/07MVH-120GH Components Honda GX160 Engine 14 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH InspectionBelt Hazard Belt Check16 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH Initial START-UPStopping the Engine Starter GripOperation MVH-120GH Operation18 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Daily Service Inspection and Maintenance ServiceTablesMachine Inspection Hours of Operation20 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH MaintenanceHydraulic Oil TroubleshootingReplacing Hydraulic Oil 22 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH Preparation for Long -TERM StorageEngine Troubleshooting MVH-120GH -TROUBLESHOOTING Engine24 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Engine TroubleshootingPlate Compactor Troubleshooting MVH-120GH -TROUBLESHOOTING Plate CompactorPart NO. Column NO. ColumnQTY. Column Remarks ColumnQty Description Remarks MVH-120GH Suggested Spare PartsName Plate and Decals MVH-120GH Name Plate and Decals28 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 DECAL, Caution MVH-120 30 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH -VIBRATING Plate AssyVibrating Plate Assy Body ASSY. Serial Number L3029 and below MVH-120GH Body ASSY. OLD Version32 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 WASHER, Lock M8 Body ASSY. Body ASSY. Serial Number L3030 and Above MVH-120GH Body ASSY. NEW Version34 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 BASE, Separate Handle Type Vibrator ASSY. Serial Number L3112 and below MVH-120GH -VIBRATOR ASSY. OLD Version36 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH Vibrator ASSY. OLD Version Vibrator ASSY. Serial Number L3113 and Above MVH-120GH -VIBRATOR ASSY. NEW Version38 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH Vibrator ASSY. NEW Version Control ASSY. Serial NO. L3080 and below MVH-120GH Control ASSY. Oldversion40 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MVH-120GH Control ASSY. OLD Version 42 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Control ASSY. Serial NO. L3081 and AboveNUT M16 MVH-120GH Control ASSY. NEW VersionCylinder Head Assy Honda GX160 Engine Cylinder Head Assy44 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 CLIP, Vlave Guide Includes Item W/ %GASKET, Cylinder Head Cover COMP., HeadCylinder Barrel Assy Honda GX160 Engine Cylinder Barrel Assy46 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 WEIGHT, Governor Switch ASSY., OIL LevelHOLDER, Governor Weight PIN, Governor WeightCrankcase Cover Assy Honda GX160 Engine Crankcase Cover Assy48 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 PACKING, OIL Filler CAP Gasket CrankcaseOIL Seal Crankshaft Assy Honda GX160 Engine Crankshaft Assy50 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Washer 8 MM BoltKEY 5X5X33 Yellow Crankshaft CompPiston Assy Honda GX160 Engine Piston Assy52 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Ring SET, Piston STD BOLT, Connecting RODRing SET, Piston Piston STDCamshaft Assy Honda GX160 Engine Camshaft Assy54 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 NUT, Pivot Adjusting SPRING, Weight ReturnROD, Push ARM, Valve RockerRecoil Starter Assy Honda GX160 Engine Recoil Starter Assy56 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Rachet Starter REEL, Recoil StarterPLATE, Friction GUIDE, RatchetFAN Cover Assy Honda GX160 Engine FAN Cover Assy58 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Shroud Comp Cover COMP., FAN NH1CLIP, Harness Alert UNIT, OILCarburetor Assy Honda GX160 Engine Carburetor Assy60 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Float Valve SET PLATE, Lever SettingFloat SET Screw SET, PilotAIR Cleaner Assy Honda GX160 Engine AIR Cleaner Assy62 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 GROMET, AIR Cleaner COVER, AIR CleanerCOLLAR, AIR Cleaner PACKING, ElbowMuffler Assy Honda GX160 Engine Muffler Assy64 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 PROTECTOR, Muffler Muffler CompDeflector Comp ARRESTOR, SparkFuel Tank Assy Honda GX160 Engine Fueltank Assy66 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 FILTER, Fuel Includes Item W/+Fuel Tank Comp Flange NUT 6 MMFlywheel Assy Honda GX160 Engine Flywheel Assy68 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 Woodruff KEY Flywheel CompFAN, Cooling PULLEY, StarterIgnition Coil Assy Honda GX160 Engine Ignition Coil Assy70 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 36101ZE1010 Control Assy Honda GX160 Engine Control Assy72 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 SPRING, Governor Wire HolderBOLT, Governor ARM ARM, GovernorLabel Assy Honda GX160 Engine Label Assy74 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 MARK, Choke Gray MARK, ChokeMARK, OIL Alert External MARK, Throttle IndicationTools Assy Honda GX160 Engine -TOOLS Assy76 MVH-120GH Operation and Parts Manual REV. #3 10/24/07 HANDLE, BOX Wrench Part NameFreight Policy 78 MVH-120GH Operation and Parts Manual REV. #3 10/24/07MVH-120GH Operation and Parts Manual REV. #03 10/24/07 HERE’S HOW to GET Help