Briggs & Stratton FIELD and BRUSH MOWER manual End of Season and Storage

Page 39

End of Season and Storage

WHEN PERFORMING ANY ADJUSTMENT OR MAINTENANCE, YOU MUST FIRST SHUT OFF THE ENGINE, WAIT FIVE (5) MINUTES TO ALLOW PARTS TO COOL AND DISCONNECT THE SPARK PLUG WIRE(S), KEEPING IT AWAY FROM THE SPARK PLUG(S).

NOTE: Please refer to the Engine Owner's Manual for Engine-specific procedures.

•Change the Engine oil and Oil Filter.

•Remove the Spark Plug(s) and pour about 1 ounce of motor oil into the Cylinder hole. Replace the Plug(s) and crank the Engine over a couple of times using the Electric Starter. This will coat the pistons and seat the valves to prevent moisture buildup.

•Clean/replace the Air Filter(s).

•Clean dirt and debris from the Cylinder Head Cooling Fins, Blower Housing, Debris Screen, and Muffler area of the Engine.

•Replace the Fuel Filter.

•If your TOW-BEHIND DR FIELD and BRUSH MOWER will be idle for more than 30 days, we recommend using a gas stabilizer. This will prevent sediment from gumming up the Carburetor. If there is dirt or moisture in the gas or tank, remove it by draining the tank. Completely fill the tank with fresh, unleaded gas and add the appropriate amount of stabilizer or gasoline additive. Run the Engine for a short time to allow the additive to circulate.

•Remove any wrapped weeds from the Blades Carrier Housing. Clean grass and debris from the top and underneath the mower Deck with a stiff brush.

•Check the Blades for nicks and wear. Remove the Blades and sharpen them, or have them professionally sharpened if needed.

•Touch-up all rusted or chipped paint surfaces. Sand them lightly before painting.

•Be sure all nuts, bolts, and screws are securely fastened.

•Inspect moving parts and the Blades’ Drive Belt for damage and wear; replace if necessary.

•Store the Battery in a dry area that will not freeze. If you will not use the machine over a long period, charge the Battery every four to six weeks. See page 33.

•If possible, store your TOW-BEHIND DR FIELD and BRUSH MOWER inside, but not near an open flame or spark such as found in a water heater.

•After the TOW-BEHIND DR FIELD and BRUSH MOWER has cooled, cover the machine with a suitable protective cover that does not retain moisture. Do not use plastic as this material cannot breathe; it also allows condensation to form, which will cause your machine to rust.

CALL TOLL-FREE 1-800-DR-OWNER

35

Page 38 Page 40
Image 39
Page 38 Page 40
Contents Safety & Operating Instructions Meigs Road Vergennes, VT Toll-Free phone 1-800-DR-OWNER Fax Table of Contents Parts LISTS, Schematic Diagrams and Warranty Conventions used in this manual IntroducingHP Model SpecificationsLabels General Safety RulesTOW-BEHIND DR Field and Brush Mower Protecting Yourself and Those Around You Slope Operation Safety for ChildrenSafety with Gasoline-Powered Machines For Assistance General SafetyAdditional Information and Potential Changes TOW-BEHIND DR Field and Brush Mower DR-OWNER Setting UPFuel Tank TOW-BEHIND DR Field and Brush Mower Controls and FeaturesUnpacking and Assembling the Machine Parts Supplied in CrateTools and Supplies Needed About the Battery Connecting the Battery WireTools Needed Approximate Engine Oil Required Adding Oil and GasolineTool Needed Connecting the Remote Control Cable and Wire Cord Wire CordThrottle Control Cable 13 HP B&S Tool Needed Throttle/Choke Cable 17 HP Kawasaki Tool Needed Hitch Plate Checking the Tire Pressure Operating Parameters OperatingTOW-BEHIND DR Field and Brush Mower Before Starting the Engine StartingStopping the Engine Adjusting the Mower Deck Height Engaging the BladesStopping the Blades Offset Mowing Offset at the Tow Bar Mount PlateOffset at the Versa-Hitch Cutting Wet and Heavy Growth Slopes and Uneven TerrainIf the machine gets hung up Cutting Brush and SaplingsEvery 10 Hrs Every 25 Hrs Regular Maintenance Check ListProcedure MaintainingSure That the OLD Filter Gasket Comes OFF with the Filter Removing the Engine Oil and FilterCall TOLL-FREE 1-800-DR-OWNER Removing and Replacing the Blades’ Drive BeltBelt Tension Spring Mounting Stud 15/16 Wrench Gloves Removing and Replacing the Swinging BladesReplacing the Wheels Charging the Battery Battery CareRecycling a Used Battery Disposing of the Battery ResponsiblyEnd of Season and Storage TOW-BEHIND DR Field and Brush Mower Troubleshooting Table TroubleshootingEngine smokes Call 1-800-DR-OWNER 376-9637 for assistance Uneven cutTOW-BEHIND DR Field and Brush Mower Parts LISTS, Schematic Diagrams and Warranty Parts List Deck and Drive AssemblyRef# Part# Description Items Not Illustrated Safety and Information LabelsSchematic Deck and Drive Assembly Part# Description Parts List Wheels and Push Bar AssemblySchematic Wheels and Push Bar Assembly Ref# Part# Description Items Not Illustrated Parts List Tow Bar and Remote Control Panel AssemblySchematic Tow Bar and Remote Control Panel Assembly TOW-BEHIND DR Field and Brush Mower Call Toll Free 1-800-DR-OWNER TOW-BEHIND DR Field and Brush Mower Year Limited Warranty Daily Checklist for the TOW-BEHIND DR Field and Brush Mower
Top Page Image Contents