Exmark Lazer HP manual Adjustments, Service Interval 500 hrs

Page 42

Do not change hydraulic system oil (except for what can be drained when changing filter), unless it is felt the oil has been contaminated or been extremely hot.

Changing oil unnecessarily could damage hydraulic system by introducing contaminates into the system.

5.1.26Wheel hub - slotted nut torque specification.

Service Interval: 500 hrs

When tightening the slotted nut on the wheel motor tapered shaft:

a)Torque the slotted nut to 125 ft. lbs (169 N-M).

b)Check distance from bottom of slot in nut to inside edge of hole. Two threads (0.1”) or less should be showing.

c)If more than two threads (0.1”) are showing remove nut and install washer (PN 1-523157) between hub and nut.

d)Torque the slotted nut to 125 ft. lbs (169 N-M).

e)Then tighten nut until the next set of slots line up with the cross hole in shaft.

f)Replace cotter pin.

NOTE: Do not use antisieze on wheel hub.

5.1.27Fuel Tank – mounting hardware specification.

When installing the nuts on the fuel tank studs, fully tighten the nyloc nut and back off 1/2 turn. This allows for normal fuel tank expansion and contraction with changes in temperature and fuel levels.

5.1.28Thread locking adhesives such as “Loctite 242” or “Fel-Pro, Pro-Lock Nut Type” are used on the following fasteners:

a)Pump drive sheave set screws.

b)Square head setscrews on Hydro pump control arms.

c)Sheave retaining bolt in the end of engine crankshaft.

d)Caster wheel spacer nuts

e)Fuel tank bulkhead fitting nuts.

Adhesives such as “Loctite RC/609 or RC/680” or “Fel-Pro Pro-Lock Retaining I or Retaining II” are used on the following:

a)Fuel tank studs, where studs are inserted into tank.

5.1.29Mobil HTS grease (or food-grade antisieze) is used in the following locations:

a)Between the cutter housing spindle and bearings.

b)Between the cutter housing spindle and sheave.

c)Under top cutter housing bearing guard.

d)Between jackshaft and bearings and jackshaft and sheaves.

5.1.30Dielectric grease is used on all blade type electrical connections to prevent corrosion and loss of contact.

5.2 ADJUSTMENTS

IMPORTANT: Disengage PTO, shut off engine, wait for all moving parts to stop, and remove key before servicing, cleaning, or making any adjustments to the unit.

5.2.1Cutting Height Adjustment.

a)Stop machine and move drive levers out to neutral lock position.

b)Disengage PTO.

c)Raise the deck lever to the transport position (also the 5” (12.7 cm) cutting height position). See Figure 10.

- 37 -

Image 42
Contents For Serial Nos 440,000 & Higher Potential Hazard Exmark Parts PLUS Program Operators Manual Table of Contents Safety Alert Symbol SafetyYour Safety is Involved TrainingCarbon monoxide can kill you Potential Hazard Operation Safe Zone for Mowing There is no rollover protection when the roll bar is down Maintenance and Storage For Kawasaki Liquid-Cooled units Safety Signs Page Location RH Side on Top Specifications Hydrostatic Ground Drive System TiresCutting Deck Dimensions Torque RequirementsAssembly Instructions Uncrate Mower Install Rollover Protection System Roll BARLower Roll BAR Installation Service Battery Upper Roll BAR InstallationMachine is shipped with a filled lead acid battery Install Drive Wheels Install Motion Control LeversCheck Tire Pressure Service Engine Service Engine Coolant Position Discharge ChuteControls Service Hydraulic OILOperation Instructions Motion Control PositionsPotential Hazard Push the lever forward and down to disengage the brake PRE-START Operating InstructionsTransporting Do not drive a unit on a public street or roadway Maintenance & Adjustments Periodic MaintenanceService Interval Daily Service Interval Monthly Service Interval Daily or more often in dry conditions Blade Bolt Installation Service Interval Daily Service Interval 50 hours Service Interval 100 hrsCoolant Plug Location Service Interval 40 hr Service Interval 40 hrsLubrication Chart Service Interval Refer to chartService Interval Once Yearly Caster Wheel AssemblyService Interval 160 hrs Service Interval As Required Service Interval After First 250 hrs Then yearly thereafterAdjustments Service Interval 500 hrsANTI-SCALP Roller Adjustment Cutting Height PositionSwivel Adjustment Spring Compression Adjustment Self-tensioning No adjustment necessaryMule Drive Belt Adjustment Brake Adjustment Belt Guide PositioningNo adjustment necessary Reverse Indicator AdjustmentThrottle Tension Motion Control Adjustment Caster Adjustment Armrest AdjustmentMotor OIL Disposal Mercury Switch DisposalWaste Disposal Engine Coolant DisposalMower Pulls Left or Right W/LEVERS Fully Forward Trouble ShootingBattery Disposal Mower Cuts UnevenlyEngine Troubleshooting Table ProblemEngine Warning Systems Electrical Diagram Hydraulic Diagram Limited Warranty Exmark Turf Equipment Page Page Service Record Page See EXMARK’S Complete Line of Products for Turf Care