Hayter Mowers 30-Dec manual HOW to Replace the Motion Drive Belt, Removal

Page 30

MAINTENANCE

HOW TO REPLACE THE MOTION DRIVE BELT

REMOVAL

1.Remove the mower housing. See the instructions on “How To Remove The Mower Housing”.

2.Completely push the pedal forward and engage the parking brake.

3.Remove the idler pulley (Figure 27).

4.Loosen the belt guides that are around the drive pulley.

5.Remove the motion drive belt from the drive pulley.

6.To remove the motion drive belt from the stack pulley, pull the front end of the belt under the stack pulley and then back between the stack pulley and the belt guide plate (Figure 28).

7.Put the end of the motion drive belt from the drive pulley through the hole for the shift lever (Figure 29). Move the shift lever and push the belt under the shift lever.

8.Remove the motion drive belt. A correct replacement part or assistance is available from an Authorized Service Center in your area.

INSTALLATION

1.Slide the motion drive belt between the stack pulley and the belt guide plate (Figure 28). Install the motion drive belt on the top pulley of the stack pulley. Make sure the “V” side of the belt is against the pulley.

2.Push the motion drive belt through the hole in the frame for the shift lever (Figure 29). Lift the end of the belt over the shift lever and back down through the hole in the frame.

3.Install the end of the motion drive belt around the drive pulley (Figure 27).

4.Tighten the belt guides that are around the drive pulley.

5.Put the belt around the idler pulley. Assemble the idler pulley. Fasten the idler pulley with the hex nut. Make sure the flat side of the belt is against the idler pulley as shown. Also, make sure the belt is not twisted.

6.Make sure the motion drive belt is inside all the belt guides (Figure 27 and Figure 28).

7.Before you use the unit, check the adjustment of the clutch. See the instructions “How To Check And Adjust The Clutch”.

8.Install the mower housing. See the instructions “How To Install The Mower Housing”.

Drive Pulley

Motion

Drive Belt

Idler Pulley

Loosen The

Belt Guides

Figure 27

FRONT

Belt Guides

Belt Guide

Plate

Motion

Drive Belt

Stack Pulley

Figure 28

Shift Lever

Motion Drive Belt

Figure 29

F−98857

30

Page 29 Page 31
Image 30
Page 29 Page 31
Contents 12/30 Table of Contents International Symbols Safety Warning SymbolsTraining OWNER’S Information Slope Operation Safe Mowing Guide Safe Mowing Guide Safe Mowing Guide Steps to Follow Before MowingAssembly AssemblyHOW to Install the Front Wheels HOW to Assemble the Lift LeverMaintenance Free Battery HOW to Charge the Maintenance Free BatteryHOW to Install the Seat HOW to Assemble the Steering WheelCheck the Tyres HOW to Prepare the EngineCheck the Level of the Mower Housing IMPORTANT! Before YOU Start MowingOperation Location of ControlsLift Lever HOW to USE the Throttle Control HOW to USE the Shift LeverAttachments HOW to Stop the Unit HOW to SET the Parking BrakeHOW to Change the Cutting Height HOW to Transport the UnitHOW to Operate with the Mower Housing HOW to Operate the Unit on HillsBefore Starting the Engine HOW to Start the EngineHOW to Start with a Weak Battery CarburettorOperating Tips Mowing and Bagging TipsHOW to Check the Muffler MaintenanceMaintenance Chart General RecommendationsHOW to Remove and Install the Blade HOW to Sharpen the BladeInspect Blade HOW to Adjust the Blade Rotation Control HOW to Check and Adjust the Drive Brake HOW to Check and Adjust the ClutchHOW to Clean the Battery Where to Lubricate HOW to Check the Fuel FilterHOW to Remove the Mower Housing HOW to Install the Mower HousingHOW to Level the Mower Housing Front to Back AdjustmentSide to Side Adjustment HOW to Replace the Motion Drive Belt RemovalHOW to Replace the Mower Drive Belt HOW to Clean the Mower Housing HOW to Replace the FuseHOW to Replace the Light Bulb BatteryTrouble Shooting Chart Problem The engine will not startIndex AFO Slope Guide −98857 Repair Parts Model CODE143P Repair Parts Chassis & Hood Key Description Model CODE143P Repair Parts Motion Drive Model CODE143P Motion DriveSteering Model CODE143P Repair Parts Steering Key Part DescriptionModel CODE143P Repair Parts Mower Housing Suspension Model CODE143P Repair Parts Mower Housing Suspension Model CODE143P Repair Parts Mower Housing Key Description Electricalrepair Parts Model CODE143P Repair Parts Electrical System Model CODE143P Repair Parts Engine Mount Model CODE143P Repair Parts Engine Mount −98857
Top Page Image Contents