Cleaning, To Change Engine OIL See Fig, Muffler

MAINTENANCE

TO CHANGE ENGINE OIL (See Fig. 10)

NOTE: Before tipping lawn mower to drain oil, empty fuel tank by running engine until fuel tank is empty.

1.Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug.

2.Remove engine oil cap; lay aside on a clean surface.

3.Tip lawn mower on its side as shown and drain oil into a suitable container. Rock lawn mower back and forth to remove any oil trapped inside of engine.

CONTAINER

FIG. 10

4.Wipe off any spilled oil from lawn mower or side of engine.

5.Slowly pour oil down the oil ﬁ ll spout, stopping every few ounces to check the oil level with the dipstick.

6.Stop adding oil when you reach the FULL mark on the dipstick. Wait a minute to allow oil to settle.

7.Continue adding small amounts of oil, rechecking the dipstick until oil level settles at FULL. DO NOT over- ﬁ ll, or engine will smoke heavily from the mufﬂ er on startup.

8.Always be sure to retighten oil dipstick before starting engine.

9.Reconnect spark plug wire to spark plug.

AIR FILTER (See Fig. 11)

Your engine will not run properly using a dirty air ﬁ lter. Replace paper cartridge every 100 hours of operation or every season, whichever occurs ﬁ rst. Service air cleaner more often under dusty conditions.

1.Loosen screws and remove cover.

2.Carefully remove cartridge.

3.Clean by gently tapping on a ﬂ at surface. If very dirty, replace cartridge.

CAUTION: Petroleum solvents,such as kerosene, are not to be used to clean cartridge.Theymaycausedeterioration of the cartridge. Do not oil cartridge. Do not use pressurized air to clean or dry cartridge.

4. Install cartridge, then replace cover.

SCREWS

COVER

CARTRIDIGE

BASE

FIG. 11

MUFFLER

Inspect and replace corroded mufﬂ er as it could create a ﬁ re hazard and/or damage.

SPARK PLUG

Replace spark plug at the beginning of each mowing season or after every 100 hours of operation, whichever occurs

ﬁrst. Spark plug type and gap setting are shown in the “PRODUCT SPECIFICATIONS” section of this manual.

CLEANING

IMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN THE UNDERSIDE OF YOUR MOWER AFTER EACH USE.

CAUTION: Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with plug.

•Clean the underside of your lawn mower by scraping to remove build-up of grass and trash.

•Clean engine often to keep trash from accumulating. A clogged engine runs hotter and shortens engine life.

•Keep ﬁ nished surfaces and wheels free of all gasoline, oil, etc.

•We do not recommend using a garden hose to clean lawn mower unless the electrical system, mufﬂ er, air ﬁ lter and carburetor are covered to keep water out. Water in engine can result in shortened engine life.