Husqvarna owner manual Tractor - Model NO. GT2254 96023000500 Product no 23, Schematic

Page 29

TRACTOR - - MODEL NO. GT2254 (96023000500) PRODUCT NO. 960 23 00-05

SCHEMATIC

BATTERY

SOLENOID

RED	A	RED	RED

AMMETERFUSE (OPTIONAL)

WHITEPTO (DISENGAGED)

M

STARTER

B S M

GA1

L A2

IGNITION SWITCH

WHITE

BLACK

CLUTCH / BRAKE

(PEDAL UP)

GRAY

SEAT SWITCH

(NOT OCCUPIED)

BLACK	BLACK
BLACK	GRAY

	REVERSE SWITCH
	SHORTING CONNECTOR
BLACK	NOT IN REVERSE
	BLACK
	ELECTRIC CLUTCH

BLACK

RED

BLACK / WHITE

BLUE

FUEL SHUT-OFF

SOLENOID

FUEL

LINE

BLUE

(IF SO EQUIPPED)

RED

ORANGE

LIGHT SW

	IGNITION	SPARK PLUGS
	IGNITION	GAP
	UNIT	GAP
	UNIT	(2 PLUGS
		ON TWIN CYL. ENGINES)
	HOUR	BLACK

METER (OPTIONAL)

	CHARGING SYSTEM OUTPUT	28 VOLTS AC @ 3600 RPM
		(REGULATOR DISCONNECTED)
	16 AMP DC @ 3600 RPM

REGULATOR ALTERNATOR

BROWN

BLACK

NOTE

YOUR TRACTOR IS EQUIPPED WITH A SPECIAL ALTERNATOR SYSTEM. THE LIGHTS ARE NOT CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE.

BLACK

HEADLIGHTS

NON-REMOVABLE REMOVABLE

CONNECTIONS CONNECTIONS

IGNITION SWITCH

POSITION	CIRCUIT	“MAKE”
OFF	M+G+A1
RUN/OVERRIDE	B+A1
RUN	B+A1	L+A2
START	B + S + A1

	BECAUSE OF THIS, THE
	BRIGHTNESS OF THE LIGHTS	WIRING INSULATED CLIPS
	WILL CHANGE WITH ENGINE
		NOTE: IF WIRING INSULATED CLIPS
	SPEED. AT IDLE THE LIGHTS
		WERE REMOVED FOR SERVICING OF
	WILL DIM. AS THE ENGINE IS
		UNIT, THEY SHOULD BE REPLACED
	SPEEDED UP, THE LIGHTS
		TO PROPERLY SECURE YOUR WIRING.
	WILL BECOME THEIR BRIGHTEST.

02832

29

Image 29

Contents GT2254 II. Slope Operation Safe Operation Practices for Ride-On MowersGeneral Operation General Service ServiceIII. Children IV. TowingTable of Contents Steering Wheel Gauge Wheels Unassembled PartsSeat Slope SheetTools Required for Assembly AssemblyTo Remove Tractor from Carton Before Removing Tractor from SkidAssemble Gauge Wheels to Mower Deck See Install Seat See FigInstall Mower and Drive Belt Sees Check Deck Levelness Check Tire PressureCheck for Proper Position of ALL Belts Check Brake SystemOperation Know Your Tractor Height Adjustment Knob Used to adjust the mower heightHOW to USE Your Tractor Using the Reverse Operation System To Adjust Gauge Wheels See FigTo Operate Mower See Fig Reverse Operation System ROSBefore Starting the Engine Mowing Tips Lubrication Chart MaintenanceGeneral Recommendations Before Each USETo Sharpen Blade See Fig TractorBlade Removal See Fig Engine BatteryBelts Transaxle CoolingCleaning To Install Mower Service and AdjustmentsTo Level Mower Housing To Remove Mower See FigFRONT-TO-BACK Adjustment See Figs Belt Routing To Replace Mower Drive Belt See FigTo Replace Motion Drive Belt See Fig To Adjust Attachment Clutch See FigTo Check and Adjust Brake See Fig To Adjust Steering Wheel ALIGN- Ment Transmission REMOVAL/REPLACEMENTTo Start Engine with a Weak Battery See Fig Front Wheel TOE-IN/CAMBERTo Adjust Choke Control To Adjust Throttle Control CableTo Adjust Carburetor To Replace FuseFuel System OtherEngine OIL CylindersProblem Cause Correction Troubleshooting PointsEngine dies when Tractor - Model NO. GT2254 96023000500 Product no 23 SchematicElectrical KEY Part Description 532 14 Battery167 Chassis and EnclosuresRepair Parts Ground Drive Repair Parts Steering Assembly 532 19 Wheel, Steering Engine Engine Briggs, Model No H777Order parts from engine 532 19 Seat Seat AssemblyWheels & Tires DecalsLift Assembly Repair Parts Mower Deck Repair Parts Gear Drive Transaxle 532 00 Needle Bearing Service Notes Service Notes Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationLimited Warranty Warranty Statement532 19 61-68 Rev 05.16.05 TR