Husqvarna GT2254 owner manual Repair Parts

Page 43

REPAIR PARTS

TRACTOR - - MODEL NO. GT2254 (96023000500) PRODUCT NO. 960 23 00-05

LIFT ASSEMBLY

KEY	PART
NO.	NO.	DESCRIPTION

1532 12 10-06 Rod Asm., Lever

2532 18 00-45 Shaft Asm., Lift Vgt

3532 15 91-89 Lever Asm., Lift Rh

4812 00 00-22 E-Ring Truarc #5133-87

5819 29 20-16 Washer 29/32 x 1-1/4 x 16 Ga.

6871 11 06-24 Bolt, Fin Hex 3/8-16 x 1-1/2

7	532 12 56-31	Grip, Handle
8	532 12 45-26	Button, Plunger

9532 12 23-64 Plunger, Lever Lift

10	532 18 38-94	Spring 0.62 OD x 2.125
11	532 17 53-75	Link Lift
12	532 16 35-52	Retainer, Spring

23532 12 46-70 Retainer, Spring

24873 35 08-00 Nut, Jam Hex 1/2-13 unc

26	873 80 08-00	Nut, Lock W/Wsh 1/2-13 unc
29	532 15 02-33	Trunnion Inﬁn Height
30	532 11 08-07	Nut, Special

31819 13 10-16 Washer 13/32 x 5/8 x 16 Ga.

32532 13 71-50 Spring, Compression Inf Hgt

33876 02 03-08 Pin, Cotter 3/32 x 1/2

34	532 13 71-67	Rod, Adj Lift
35	532 13 80-57	Knob, Inf 3/8-16 unc

38532 15 50-97 Pointer Height Indicator

39532 12 39-35 Plug, Hole Blk. 1.485/1.515 Dia.

40817 06 05-16 Screw 5/16-18 x 1

41532 17 59-94 Nut, Crownlock 3/8-24

42819 11 24-10 Washer 11/32 x 1-1/2 x 10 Ga.

43532 12 39-34 Scale, Indicator Height

70 532 14 52-12 Nut Hex Flange Lock

72532 11 04-52 Nut Push Phos & Oil

73873 35 06-00 Nut, Hex Jam 3/8-16 unc

74532 18 72-77 Arm Suspension Rear RH

75532 17 58-05 Plate, Asm, Susp, Front

76	532 17 55-60	Pin Flange
77	532 17 62-05	Trunnion

78532 17 56-89 Trunnion, Front, Susp

79532 18 72-76 Arm, Suspension Rear LH

85	532 18 90-13	Insert Wear
86	532 18 85-28	Bolt Shoulder

NOTE: All component dimensions given in U.S. inches 1 inch = 25.4 mm

43

Image 43

Contents GT2254 General Operation Safe Operation Practices for Ride-On MowersII. Slope Operation IV. Towing ServiceGeneral Service III. ChildrenTable of Contents Slope Sheet Unassembled PartsSteering Wheel Gauge Wheels SeatBefore Removing Tractor from Skid AssemblyTools Required for Assembly To Remove Tractor from CartonAssemble Gauge Wheels to Mower Deck See Install Seat See FigInstall Mower and Drive Belt Sees Check Brake System Check Tire PressureCheck Deck Levelness Check for Proper Position of ALL BeltsOperation Know Your Tractor Height Adjustment Knob Used to adjust the mower heightHOW to USE Your Tractor Reverse Operation System ROS To Adjust Gauge Wheels See FigUsing the Reverse Operation System To Operate Mower See FigBefore Starting the Engine Mowing Tips Before Each USE MaintenanceLubrication Chart General RecommendationsBlade Removal See Fig TractorTo Sharpen Blade See Fig Transaxle Cooling BatteryEngine BeltsCleaning To Remove Mower See Fig Service and AdjustmentsTo Install Mower To Level Mower HousingFRONT-TO-BACK Adjustment See Figs Belt Routing To Replace Mower Drive Belt See FigTo Check and Adjust Brake See Fig To Adjust Attachment Clutch See FigTo Replace Motion Drive Belt See Fig Front Wheel TOE-IN/CAMBER Transmission REMOVAL/REPLACEMENTTo Adjust Steering Wheel ALIGN- Ment To Start Engine with a Weak Battery See FigTo Replace Fuse To Adjust Throttle Control CableTo Adjust Choke Control To Adjust CarburetorCylinders OtherFuel System Engine OILProblem Cause Correction Troubleshooting PointsEngine dies when Tractor - Model NO. GT2254 96023000500 Product no 23 SchematicElectrical KEY Part Description 532 14 Battery167 Chassis and EnclosuresRepair Parts Ground Drive Repair Parts Steering Assembly 532 19 Wheel, Steering Engine Engine Briggs, Model No H777Order parts from engine 532 19 Seat Seat AssemblyWheels & Tires DecalsLift Assembly Repair Parts Mower Deck Repair Parts Gear Drive Transaxle 532 00 Needle Bearing Service Notes Service Notes Only Ride UP and Down Hill Not Across Hill Degrees MAX Suggested Guide for Sighting Slopes for Safe OperationLimited Warranty Warranty Statement532 19 61-68 Rev 05.16.05 TR