Husqvarna GTH27V52LS owner manual Mowing Tips, Purge Transmission, Automatic Transmission Warm UP

Page 13

OPERATION

COLD WEATHER STARTING (50° F (10°C) and below)

•When engine starts, allow engine to run with the throttle control in the choke position until the engine runs roughly, then move throttle control to fast posi- tion. This may require an engine warm-up period from several seconds to several minutes, depending on the temperature.

AUTOMATIC TRANSMISSION WARM UP

•Before driving the unit in cold weather, the transmission should be warmed up as follows:

•Be sure the tractor is on level ground.

•Release the parking brake and let the brake slowly return to operating position.

•Allow one minute for transmission to warm up. This can be done during the engine warm up period.

•Theattachmentscanalsobeusedduringtheenginewarm- up period after the transmission has been warmed up.

NOTE: If at a high altitude (above 3000 feet) or in cold temperatures (below 32° F (0°C) the carburetor fuel mixture may need to be adjusted for best engine performance. See “TO ADJUST CARBURETOR” in the Service and Adjust- ments section of this manual.

PURGE TRANSMISSION

CAUTION: Never engage or disengage freewheelleverwhiletheengineisrunning.

To ensure proper operation and performance, it is recom- mended that the transmission be purged before operating tractor for the first time. This procedure will remove any trapped air inside the transmission which may have devel- oped during shipping of your tractor.

IMPORTANT: SHOULD YOUR TRANSMISSION REQUIRE REMOVAL FOR SERVICE OR REPLACEMENT, IT SHOULD BE PURGED AFTER REINSTALLATION BEFORE OPERATING THE TRACTOR.

1.Place tractor safely on a level surface - that is clear and open - with engine off and parking brake set.

2.Disengage transmission by placing freewheel control in disengaged position (See “TO TRANSPORT” in this section of manual).

3.Sitting in the tractor seat, start engine. After the en- gine is running, move throttle control to slow position. Disengage parking brake

CAUTION: At any time, during step 4, there may be movement of the drive wheels.

4.Depress forward drive pedal to full forward position, hold for five (5) seconds and release pedal. Depress reverse drive pedal to full reverse position, hold for five

(5) seconds and release pedal. Repeat this procedure three (3) times.

5.Shut- off engine and set parking brake.

6.Engage transmission by placing freewheel control in engaged position (See “TO TRANSPORT” in this sec- tion of manual).

7.Sitting in the tractor seat, start engine. After the engine is running, move throttle control to half (1/2) speed. Disengage parking brake.

8.Drive tractor forward for approximately five feet then backwards for five feet. Repeat this driving procedure three times.

Your transmission is now purged and now ready for normal operation.

MOWING TIPS

•Mower should be properly leveled for best mowing performance. See “TO LEVEL MOWER HOUSING” in the Service and Adjustments section of this manual.

•The left hand side of mower should be used for trim- ming.

•Drive so that clippings are discharged onto the area that has been cut. Have the cut area to the right of the machine. This will result in a more even distribution of clippings and more uniform cutting.

•When mowing large areas, start by turning to the right so that clippings will discharge away from shrubs, fences, driveways, etc. After one or two rounds, mow in the opposite direction making left hand turns until finished (See Fig. 14).

Fig. 14

•If grass is extremely tall, it should be mowed twice to reduce load and possible fire hazard from dried clip- pings. Make first cut relatively high; the second to the desired height.

•Do not mow grass when it is wet. Wet grass will plug mower and leave undesirable clumps. Allow grass to dry before mowing.

•Always operate engine at full throttle when mow- ing to ensure better mowing performance and proper discharge of material. Regulate ground speed by selecting a low enough gear to give the mower cutting performance as well as the quality of cut desired.

•When operating attachments, select a ground speed that will suit the terrain and give best performance of the attachment being used.

13

Page 12 Page 14
Image 13
Page 12 Page 14
Contents GTH27V52LS Safe Operation Practices for Ride-On Mowers Safety RulesGeneral Operation II. Slope OperationGeneral Service ServiceIII. Children IV. TowingTable of Contents Tools Required for Assembly AssemblyUnassembled Parts ToremovetractorfromcartonCheck Deck Levelness Check Tire PressureCheck for Proper Position of ALL Belts Check Brake SystemOperation Know Your Tractor Attachment Clutch Switch Disengaged Engaged HOW to USE Your TractorTo SET Parking Brake See Fig Stopping See FigTo Adjust Gauge Wheels See Fig To Adjust Mower Cutting Height See FigTo Move Forward and Backward See Fig To USE Cruise Control J See FigTo Stop Mower Blades Using the Reverse Operation SystemReverse Operation System ROS See Fig To Operate on HillsBefore Starting the Engine Service REMINDER/HOUR MeterCheck Engine OIL Level ADD GasolinePurge Transmission Mowing TipsAutomatic Transmission Warm UP Maintenance MaintenanceGeneral Recommendations ScheduleTractor BatteryBlade Care Blade Removal See FigEngine IN-LINE Fuel Filter See Fig CleaningDeck Washout Port See Fig To Install Mower See Fig Service and AdjustmentsInstall ANTI-SWAY BAR S if Equipped To Remove Mower See FigSecure with small washer and small retainer spring as shown To Level Mower To Check Brake To Replace Mower Blade Drive BeltTo Replace Motion Drive Belt See Fig Belt InstallationFront Wheel TOE-IN/CAMBER To Remove Wheel See FigReplacing Battery See Fig To Start Engine with a Weak Battery see FIGTo Remove CABLES, Reverse Order Transmission Other StorageFuel System Engine OILProblem Cause Correction Troubleshooting PointsEngine continues Service Notes Service Notes Service Notes Ggus 01.07.09 AP

GTH27V52LS specifications

The Husqvarna GTH27V52LS is a robust and versatile riding lawn tractor designed to provide an optimal mowing experience for homeowners with larger landscapes. Known for its powerful performance and advanced features, this model stands out as a reliable choice for tackling various lawn care tasks.

At the heart of the GTH27V52LS is its 27-horsepower Kohler engine, delivering ample power to handle expansive lawns with ease. The efficient engine provides a balance between performance and fuel economy, ensuring you can work for longer periods without frequent refueling. Additionally, the hydrostatic transmission allows for smooth, infinite speed control, making it simple to maneuver around obstacles and navigate uneven terrain.

One of the standout features of the GTH27V52LS is its 52-inch cutting deck, which provides an impressive cutting width for efficient mowing of large areas. The deck is designed with oversized tires that enhance traction and stability, ensuring a clean cut even on the toughest terrains. Furthermore, the deck height can easily be adjusted to suit varying grass lengths, enabling precise cutting for a polished finish.

The GTH27V52LS incorporates innovative mowing technologies, such as the Air Induction Mowing Technology, which improves airflow within the deck for a superior grass cutting and grass collection performance. This results in a healthier lawn with minimal clumping and enhanced mulching capabilities.

Comfort is also a priority in the design of the GTH27V52LS. The spacious, ergonomic seat offers ample cushioning and adjustable settings, ensuring a comfortable ride during extended mowing sessions. The easy-to-use controls are strategically located for convenience, enabling operators to maintain focus on the task at hand without interruptions.

Additional features include an integrated roll-over protection system for added safety, as well as a range of accessories, such as baggers and tow-behind attachments, that enhance the tractor’s functionality throughout the year. The durable construction and high-quality materials ensure that the Husqvarna GTH27V52LS is built to withstand the rigors of regular use, making it a long-lasting investment for any homeowner.

In summary, the Husqvarna GTH27V52LS combines power, technology, and user-friendly design, making it an outstanding choice for anyone in need of a reliable riding lawn tractor. Its exceptional performance and innovative features provide an efficient solution for maintaining large lawns, ensuring your outdoor space remains pristine year-round.
Top Page Image Contents