Chamberlain ATS211R manuals

36 pages881.53 Kb

TM
UP FORCE DOWN
FORCE
The Chamberlain Group, Inc. 845 Larch Avenue, Elmhurst, Illinois 60126
MODEL ATS 211R COMMERCIAL DOOR OPENER
- For Residential and Light Duty Commercial Use Install on Sectional Doors Only
- OWNER'S MANUAL
  - 2Start by reviewing these important safety alert symbols
    - serious injuries or death
    - Read the instructions carefully.
    - Mechanical Electrical
  - 3You'll Need Tools
    - 4Before you begin, survey your garage area. Do any of the following conditions apply to you?
      - If your door has extension springs, the opener must be installed in the center of the door.
  - 5Opener Carton Inventory
    - Hardware Inventory
      - CAUTION! Use only the screw previously removed from opener.
  - 6Assembly Section: Pages 6 7
    - Use only these screws!
  - Assembly Step 1
    - Attach the Rail to the Opener
  - Assembly Step 2
    - Attach the Chain to the Sprocket & Install the Rail Support Bracket
      - do not re-adjust the chain.
      - ALWAYS
  - Assembly Step 3
    - Tighten the Chain
  - 7IMPORTANT INST ALLATION INSTRUCTIONS To reduce the risk of severe injury or death to persons:
    - An improperly balanced door may not reverse and could result in severe injury or death.
    - Ropes connected to a garage door can cause entanglement and death.
    - 8Installation Section: Pages 8 20 Installation Step 1
      - Determine Header Bracket Location
        The door might not reverse when required, and could cause serious injury or death.
        Fasten the Header Bracket to the Wall
        Fasten the Header Bracket to the Ceiling
    - 9Installation Step 2
      - Install the Header Bracket
    - 10Installation Step 3
      - Attach the Rail to the Header Bracket
    - 11Installation Step 4
      - Position the Opener
    - 12Installation Step 5
      - Hang the Opener
        each
        The opener could fall and injure someone if it is not properly secured.
    - 13Installation Step 6
      - Install the Door Control
        The garage door could close and cause serious injury or death.
        but where the garage door is visible.
        A moving garage door could injure someone under it.
        Do NOT connect the power and operate the opener at this time.
        Install the Light
    - 14Installation Step 7
      - Install the Light
    - Installation Step 8
      - Attach the Manual Release Rope and Handle
        The rope knot could become untied and you could fall.
    - 15Installation Step 9
      - Electrical Requirements
        and
        If permanent wiring is required by your local code, refer to the following procedure:
        To prevent electrocution or fire,
        Permanent wiring connection
        The opener must be grounded.
        To avoid installation difficulties, do not run the opener at this time.
        To avoid installation difficulties, do not run the opener at this time.
    - 16The Protector System
      - must
      - Information you'll need before you begin the installation of the safety reversing sensor.
    - 17Installation Step 10
      - Install the Safety Reversing Sensor (Receiving and Sending Eyes)
        Figure 4
        Figure 5
        Hardware Shown Actual Size
        17
        Door
        Wall
        Wall or Door
        garage door tracks
        wall
        but not exceeding 6"
        Figure 3
        18Figure 6
        receiving eye
        glows steadily
        sending eye
        glows steadily,
        receiving
        sending
        receiving eye
        sending
        glow steadily
        Figure 7
        eye
        glow steadily
    - Installation Step 11
    - 19CAUTION
      - Fasten Door Bracket & Plate
    - AVERTISSEMENT
      - INSTALLATION STEP 11
        Fasten the Door Bracket
    - AVERTISSEMENT ATTENTION
      - 20Installation Step 12
        Connect Door Arm to Trolley
        Hole Alignment Alternative
        above
        cut end down
        Figure 1 Figure 2
        Figure 3
      - 21Adjustment Step 1
        Adjust the UP and DOWN Limits
        How and When to Adjust the Limits
      - Adjustment Section: Pages 21 23
      - 22Adjustment Step 2
        Adjust the Force
        up
        stops
        nuisance reversals
        up
        reverses
        at least
        How and When to Adjust the Forces
      - 23Adjustment Step 4
        Test the Safety Reverse System
      - Adjustment Step 3
        Test The Protector System
        Limit and Force Adjustment Control
  - 24IMPORTANT SAFETY INSTRUCTIONS To reduce the risk of severe injury or death to persons:
    - must
    - Care of Your Opener
      - Failure to properly adjust the opener may result in severe injury or death.
      - Weak or broken springs may cause the door to fall rapidly, causing injury or death to persons.
    - WARNING WARNING
      - Do not exceed 8 complete cycles of door operation per hour in commercial applications.
        until down travel is complete.
        reverse.
        reverse
      - 25Operation of Your Opener
        Operation of the Door Control Button
        stop
        Children operating or playing with a garage door opener can injure themselves or others.
        The garage door could close and cause serious injury or death.
        (Stop)
        (Close)
        (Open)
        With the door closed,
        hold
        large
        26
        Do not allow children to operate the Door Control or remote control transmitter(s).
        A moving garage door could injure or kill someone under it.
      - 26SECURITY3-Channel Remote Control Programming (OPTIONAL)
        NOTE: Open/Close/Stop operation counts as 1 function.
        Figure 1
        flash once. 3.
        SECURITY Garage Door Opener
        Figure 2
        Model 96LM SECURITYRemote Control
      - 27SECURITYMulti-Function Door Control - Model 58LM (OPTIONAL)
        Operation of the Multi-Function Door Control Panel
        reverse
        To Turn Off:
        To Activate:
        close
        open
        off,
        stop
        on.
        off.
        off
      - 28SECURITYMulti-Function Door Control - Model 68LM (OPTIONAL)
        Figure 1
        Alternate Installation
        For pre-wired installations,
        For standard wall mount,
        Figure 2
        reverse
        To Turn Off:
        To Activate:
        close
        open
        off,
        stop
        on.
        off.
        off
        Operation of the Multi-Function Door Control Panel
        The garage door could close and cause serious injury or death.
        but where the garage door is visible.
        A moving garage door could injure someone under it.
        Standard Installation
      - 29SECURITYKeyless Entry - Model 67LM (OPTIONAL)
        hold
        With the door closed,
      - 30Having a Problem?
        Situation Probable Cause & Solution
      - 31Having a Problem?
        (continued)
        Situation Probable Cause & Solution
      - 33Repair Parts
      - 34Accessories Available for your Opener
        Other Products For Your Opener
      - 35Index
        LIFTMASTER GARAGE DOOR OPENER ONE-YEAR LIMITED WARRANTY
        LIMITED WARRANTY ON MOTOR
  - 36LIFTMASTER SERVICE IS ON CALL
    - 1-800-528-2806
  - HOW TO ORDER REPAIR PARTS
    - 1-800-528-2806
      - 2001, The Chamberlain Group, Inc. 114A2296B All Rights Reserved Printed in Mexico