Danger | A.O. Smith BTN 120 THRU 400/A Series specs

VERTICAL STORAGE TANK AND FORCED CIRCULATION

VERTICAL STORAGE TANK AND FORCED CIRCULATION

DANGER

TEMPERATURE SETTING SHOULD NOT EXCEED SAFE USE

TEMPERATURE AT FIXTURES. SEE WATER TEMPERATURE CONTROL

WARNING ON PAGE 25. IF HIGHER PREHEAT TEMPERATURES ARE

NECESSARY TO OBTAINADEQUATE BOOSTER OUTPUT,ADD ANANTI-

SCALD VALVE FOR HOT WATER SUPPLIED TO FIXTURES.

HORIZONTAL STORAGE TANK AND FORCED CIRCULATION

13

Image 13

A.O. Smith BTN 120 THRU 400/A Series warranty Vertical Storage Tank And Forced Circulation, Danger

Contents

MODELS BTN 120 THRU 400/A Series INSTALLATION OPERATION MAINTENANCE LIMITED WARRANTYCOMMERCIAL GAS, GLASS-LINED, TANK-TYPE WATER HEATER TABLE 1. ROUGH-IN-DIMENSIONS ROUGH-IN-DIMENSIONSTABLE 3. GASAND ELECTRICAL CHARACTERISTICS FRONT VIEW FOREWORD TABLE OF CONTENTS PRECAUTIONS GENERAL SAFETY INFORMATIONGROUNDING INSTRUCTIONS CHEMICAL VAPOR CORROSION HIGH ALTITUDE INSTALLATIONS FEATURESHIGH LIMIT SWITCH ELECTRONIC IGNITION CONTROL DISHWASHING MACHINE REQUIREMENT CIRCULATING PUMPUNCRATING LOCATING THE HEATER CLEARANCES LEVELINGHARD WATER AIR REQUIREMENTS MULTIPLE HEATER MANIFOLD VENTINGUNCONFINED SPACE CONFINED SPACE TYPE B GAS VENT Multiple Gas Fired Tank-Type Heaters TABLE 6. TECHNICAL DATA VENTING TABLE 6. TECHNICAL DATA VENTING Continued WATER POTABLE HEATING AND SPACE HEATING See pages WATER LINE CONNECTIONSTHERMOMETERS Not Supplied RELIEF VALVE GENERAL INSTALLATION DIAGRAMS-TOP INLET/OUTLET USAGECODE RESTRICTIONS DANGER HORIZONTAL STORAGE TANK AND FORCED CIRCULATION VERTICAL STORAGE TANK AND FORCED CIRCULATIONTEMPERATURE SETTING SHOULD NOT EXCEED SAFE USE TEMPERATURE AT FIXTURES. SEE WATER TEMPERATURE CONTROL WITH RECIRCULATION OF SANITIZING LOOP TWO TEMPERATURE - ONE HEATER HIGH TEMPERATURE STORAGE TWO TEMPERATURE - TWO HEATERS, ONE PRE-HEATER/ONE - BOOSTER HEATER INSTALLATION DIAGRAMS-SIDE INLET/OUTLET USAGEWITH OR WITHOUT BUILDING RECIRCULATION STORAGE WITH OR WITHOUT RECIRCULATION ONE OR TWO TEMPERATURE - ONE HEATERS,HIGH TEMPERATUREHEATER WITH OR WITHOUT MIXING VALVE HEATER WITH MIXING VALVE AND RECIRCULATED SANITIZING LOOP HEATER WITH OR WITHOUT BUILING RECIRCULATION TWO TEMPERATURE - TWO PRE-HEATERS WITH MIXING VALVE OR BOOSTERTWO PRE-HEATERS WITH MIXING VALVE TWO PRE-HEATERS WITH BOOSTER HEATER CIRCULATION WITH OR WITHOUT BUILDING RECIRCULATION MEDIUM TEMPERATURE - ONE HEATER WITH AUXILIARY STORAGE TANK FORCEDVERTICAL STORAGE TANK HORIZONTAL STORAGE TANK TWO UNIT MANIFOLD KIT MANIFOLD KITSTHREE UNIT MANIFOLD KIT FOUR UNIT MANIFOLD KIT FIGURE 9 - SINGLE UNIT WIRING DIAGRAM BTN-120 THROUGH 400A HEATER WIRING GAS PRESSURE REGULATOR GAS PIPINGTABLE 7 - GAS SUPPLY LINE SIZES IN INCHES MAXIMUM CAPACITY OF PIPE IN CUBIC FEET PER HOUR MANIFOLD GAS PRESSURE IN INCHES OF WATER COLUMN ALL MODELS OPERATIONAPPROXIMATE TIME REQUIRED TO CONSUME 1 CU. FT. OF GAS AT FULL CAPACITY SEQUENCE OF OPERATION LIGHTING AND OPERATION INSTRUCTIONS FOR YOUR SAFETY READ BEFORE OPERATINGOPERATING INSTRUCTIONS CHECK THE IGNITOR ASSEMBLY PREVENTIVE MAINTENANCEIGNITOR ASSEMBLY WATER TEMPERATURE CONTROL GAS VALVES MAIN BURNERCHECKING THE INPUT FIGURE 11, IGNITOR REMOTE STORAGE TANK TEMPERATURE CONTROL VENTING SYSTEMHOT WATER ODOR ANODE ROD INSPECTION TANK CLEANOUT PROCEDURE RECOMMENDED PROCEDURE FORDELIMING SOLVENTS DELIMING USING FLO-JUG METHOD SYSTEM DIAGNOSTICS SERVICEIGNITION MODULE SYSTEM ELECTRICAL SERVICING SEQUENCE OF OPERATION FLOW CHART REPLACEMENT PARTS, SERVICE HANDBOOKS AND TRAINING AIDSREPLACEMENT PARTS SERVICEMAN OPERATIONAL CHECKLISTREMEDY COMPLAINT 4. SERVICEANDREPAIREXPENSES Model BTN Limited Warranty6. CLAIMPROCEDURE KEEPTHISWARRANTYPOSTEDADJACENTTOTHEHEATERFORFUTUREREFERENCE