Contents
INSTALLATION, OPERATING AND SERVICE INSTRUCTIONS ALLIANCETM SERIES
for SINGLE WATER HEATER INSTALLATIONS
INDIRECT-FIRED WATER HEATERS MODELS AL-26A, 40A, 53A, 79A and 119A
IMPORTANT INFORMATION - READ CAREFULLY
DANGER
N O T IC E
DANGER
Section II - Pre-Installation
Table of Contents
I. General Information
Ratings, Capacities, Weights, & Dimensions
G AL/ HR @
Table 1 Alliance Water Heater Dimension Inches
Table 2 Alliance Water Heater Capacities
Table 3 Alliance Water Heater Performance
A. Sizing
II. Pre-Installation
1. Alliance Location
C. Domestic Hot Water Priority Two options are
D. Component Location
E. Additional Recommended Components
F. Removal of Existing Domestic Water Heating System
Figure 1 Hot Water and Relief Valve Piping
III. Piping
Figure 2 Cold Water Supply Piping
Figure 4 Water Boiler Piping with Zone Circulators and a Boiler
Figure 3 Water Boiler Piping with Zone Valves and a Boiler Bypass
Bypass
Figure 6 Water Boiler Piping with Zone Circulators and without a
3. For a space heating system that utilizes ZONE VALVES WITHOUT A BOILER BYPASS, refer to Figure 5. The Alliance connection labeled BOILER SUPPLY should be piped to the boiler supply piping after the air purger and before the space heating circulator. Mount the water heater circulator as close as possible to the water heater making sure the flow arrow points toward the water heater. The use of a shut-off valve is recommended for future service convenience
Figure 5 Water Boiler Piping with Zone Valves and without a Boiler
Bypass
2. Burnham Independence Series steam boiler Refer to Figure
H. Connect steam boiler piping See Figures 7 thru
1. Burnham V-7 Series steam boiler Refer to Figure
6032703 As above, except less limit and well
Typical Steam Boiler w/Connections Available Below Water Line
during warmer months when the space heating
On new boiler installations, do not purge the boiler
due to insufficient water temperature, especially
cleaning, or purging, the water heater should be
or Single Zone Space Heating
IV. Electrical
V. Operation
VI. Service Instructions
CAUSE
VII. Trouble Shooting
PROBLEM
SOLUTION
VIII. Repair Parts
B urnham Corporation Regional Offices
INSPECTION AND/OR SERVICE PERFORMED
Inspection / Service Schedule
DATE
