Installation / Assembly
Installing Grills in Modular Carts
You will need a second person to help you to avoid damaging the grill, the transformer, or your barbecue island..
Keep fingers away from where the grill will be supported on the cart. Your fingers could become trapped and serious injury could occur..
1.Slowly lower grill unit onto the cart, making sure that screws line up with slots on top of the cart. Ensure that no electrical cords or gas lines become trapped between any part of the cart and any part of the grill.
2.The grill should sit flat on the cart all the way around. Gently realign cart sides to allow them to sit under outside lip of grill.
3.Check that all burner control knobs are in the OFF position.
4.Attach the gas connector to the LP tank.
When handling the LP gas line and connectors, do not allow them to come in contact with any metal surfaces of the cart or cabinet. Do not drop LP connectors.
Installing Grills in Barbecue Islands
You will need a second person to help you to avoid damaging the grill, the transformer, or your barbecue island..
Before installing a grill or side burner in any island or cut out, make sure that the opening is not bigger than the outside frame of the grill unit. The grill should rest on the lip of the frame. For
Pay careful attention to the location of gas lines. Gas lines should be routed away from sources of heat and should make as few bends as possible.
Check to see if gas line connections will be accessible when grill is installed.
•If gas line connections are not easily accessible when the grill is installed, support the grill above counter level and attach the gas lines to the grill.
When the gas connections are made, slide the grill into the cut out.
•If gas line connections are accessible when the grill is installed, slide the grill into the cut out and then attach the gas lines.
Be very careful not to kink gas lines when lowering the grill or side burner into the cut out.
Keep your fingers away from where the grill will be supported on counter. Your fingers could become trapped and serious injury could occur.
Check to make sure the grill is level and is supported around the entire outside edge. If the grill is not level or is unstable, use
Perform the leak test procedure as described earlier in this manual.
Page 12 | 2007 Barbecue Grill and Cart Owner’s Manual |