Manuals
/
Char-Broil
/
Kitchen Appliance
/
Convection Oven
Char-Broil
415.9011211, 466224611 manual
Models:
415.9011211
466224611
1
29
32
32
Download
32 pages
16.52 Kb
25
26
27
28
29
30
31
32
<
>
Troubleshooting
Install
Parts list
Parts Diagram
cannot be stopped do not try to repair. Call for replacement
Warranty
Leak test new and exchanged LP cylinders BEFORE connecting to grill
Problem
If you have questions or need assistance during assembly
Check Procedure
Page 29
Image 29
NOTES
29
Page 28
Page 30
Page 29
Image 29
Page 28
Page 30
Contents
please call
Estimated assembly time 30 minutes
Serial Number
Date Purchased
TABLE OF CONTENTS
INSTALLER/ASSEMBLER
Safety Symbols
DANGER
Wash your hands after handling this product
Installation Safety Precautions
CALIFORNIA PROPOSITION
Never fill a cylinder beyond 80% full
USE AND CARE
LP Cylinder Removal, Transport and Storage
LP Liquefied Petroleum Gas
For your safety
Leak test new and exchanged LP cylinders BEFORE connecting to grill
LP Cylinder Exchange
LP Cylinder Leak Test
Outdoor gas appliance is not intended to be installed in or on an RV
Outdoor gas appliance is not intended to be installed in or on a boat
Leak Testing Valves, Hose and Regulator
Do not use grill until leak-tested
For Safe Use of Your Grill and to Avoid Serious Injury
Safety Tips
Do not let children operate or play near grill
Do not block holes in sides or back of grill
General Grill Cleaning
Turn controls and gas source or tank OFF when not in use
Ignitor Lighting continued
Match-Lighting
Storing Your Grill
Cleaning the Burner Assembly
VERY IMPORTANT Burner tubes must reengage valve
1. Turn gas OFF at control knobs and LP cylinder
SCOPE OF COVERAGE
LIMITED WARRANTY
PERIOD OF COVERAGE
TYPE OF FAILURE COVERAGE
ASSEMBLY MANUAL, ENGLISH
PARTS LIST
ASSEMBLY MANUAL, FRENCH
NOT Pictured
PARTS DIAGRAM
ASSEMBLY
Lower back panel 1/4-20x1/2” screw Qty.4 7mm lock washer Qty.4
four1/4-20x1/2” screws, 7mm lock washers, and 7mm flat washers
7mm flat washer Qty.4
1/4-20x1/2” screw 7mm lock washer 7mm flat washer
washer
Upper back panel Lower back panel
washer
self-tapping screw
Now you may fully tighten lower screws on upper back panel
Qty.1
Back of main control panel
Back of the panel
Temperature gauge
Knob bezel Control panel
Knob
Sideburner burner
Electrode
Front
Rear
#8x3/8” self-tapping screw Qty.3
self-tapping screw
AA battery
Wire
Ignition Module. Total 2 connections, shown A
+ Cap
Warming rack Cooking grate
Heat diffuser
Grease tray
On back of grill, slide grease tray into opening in upper back panel
Cylinder screw
Cylinder screw at rear of cart
Regulator
Prevention/Solution
Troubleshooting
Problem
GAS ISSUES
Problem
Troubleshooting continued
Prevention/Solution
AUTO-CLEAN
Problem Ignition
Troubleshooting - Electronic Ignition
Check Procedure
Prevention/Solution
Page
Page
Page
P.O. Box Columbus, GA
Warranty Registration Department
