Manuals
/
Char-Broil
/
Kitchen Appliance
/
Convection Oven
Char-Broil
466224611, 415.9011211 manual
Models:
415.9011211
466224611
1
32
32
Download
32 pages
16.52 Kb
25
26
27
28
29
30
31
32
<
>
Troubleshooting
Install
Parts list
Parts Diagram
cannot be stopped do not try to repair. Call for replacement
Warranty
Leak test new and exchanged LP cylinders BEFORE connecting to grill
Problem
If you have questions or need assistance during assembly
Check Procedure
Page 32
Image 32
Page 31
Page 32
Image 32
Page 31
Contents
Estimated assembly time 30 minutes
please call
Serial Number
Date Purchased
INSTALLER/ASSEMBLER
TABLE OF CONTENTS
Safety Symbols
DANGER
Wash your hands after handling this product
Installation Safety Precautions
CALIFORNIA PROPOSITION
USE AND CARE
Never fill a cylinder beyond 80% full
LP Cylinder Removal, Transport and Storage
LP Liquefied Petroleum Gas
Leak test new and exchanged LP cylinders BEFORE connecting to grill
For your safety
LP Cylinder Exchange
LP Cylinder Leak Test
Outdoor gas appliance is not intended to be installed in or on a boat
Outdoor gas appliance is not intended to be installed in or on an RV
Leak Testing Valves, Hose and Regulator
Do not use grill until leak-tested
Safety Tips
For Safe Use of Your Grill and to Avoid Serious Injury
Do not let children operate or play near grill
Do not block holes in sides or back of grill
Turn controls and gas source or tank OFF when not in use
General Grill Cleaning
Ignitor Lighting continued
Match-Lighting
Cleaning the Burner Assembly
Storing Your Grill
VERY IMPORTANT Burner tubes must reengage valve
1. Turn gas OFF at control knobs and LP cylinder
LIMITED WARRANTY
SCOPE OF COVERAGE
PERIOD OF COVERAGE
TYPE OF FAILURE COVERAGE
PARTS LIST
ASSEMBLY MANUAL, ENGLISH
ASSEMBLY MANUAL, FRENCH
NOT Pictured
PARTS DIAGRAM
ASSEMBLY
four1/4-20x1/2” screws, 7mm lock washers, and 7mm flat washers
Lower back panel 1/4-20x1/2” screw Qty.4 7mm lock washer Qty.4
7mm flat washer Qty.4
1/4-20x1/2” screw 7mm lock washer 7mm flat washer
Upper back panel Lower back panel
washer
washer
Now you may fully tighten lower screws on upper back panel
self-tapping screw
Qty.1
Back of main control panel
Temperature gauge
Back of the panel
Knob bezel Control panel
Knob
Electrode
Sideburner burner
Rear
Front
#8x3/8” self-tapping screw Qty.3
self-tapping screw
Wire
AA battery
Ignition Module. Total 2 connections, shown A
+ Cap
Heat diffuser
Warming rack Cooking grate
On back of grill, slide grease tray into opening in upper back panel
Grease tray
Cylinder screw
Cylinder screw at rear of cart
Regulator
Troubleshooting
Prevention/Solution
Problem
GAS ISSUES
Troubleshooting continued
Problem
Prevention/Solution
AUTO-CLEAN
Troubleshooting - Electronic Ignition
Problem Ignition
Check Procedure
Prevention/Solution
Page
Page
Page
Warranty Registration Department
P.O. Box Columbus, GA
